You are on page 1of 14
Maintenance categories under normal and bad cond = Driving under normal conditions Maintenance ns Conduct periodic maintenance according to the maintenance cycle in the maintenance plan. Maintenance interval Models/Item First maintenance General maintenance Special maintenance Diesel engine vehicles|5,000 km or 6 months| Every 15,000 km or 12 months Note:The Euro IV engine oll of Cl-4 SWIA0 and the diesel with sulfur content less than 50 ppm, the Euro V engine oil of CJ-4 ISW/40 and the diesel with sulfur content less than 15 ppm, are Istrongly recommended for keeping normal vehicle maintenance interval. lAfter reaching 20L4E gasoline engine| vehicles 5,000 km or 6 months Every 10,000 km or 12 months regulated mileage lor time, add special Note: The engine oll of ACEA C3 5W-30 or above specification fully synthetic engine oil, and the credibility of good international loil company are strongly recommended for keeping normal lvehicle maintenance interval. And when the vehicle mileage is Imore than 7,500 km, please check the dipstick, if the oil level is lbelow the “MIN” mark, please refill. Imaintenance items lbased on general maintenance. 4G69S4N gasoline engine vehicles __[5:200 km or 6 months Every 5,000 km or 12 months Caution : The mileage and time specified in the maintenance interval are subject to whichever comes the first. = Driving under bad conditions For driving under conditions worse than normal vehicle service conditions to shorten the maintenance interval. For example: ~ Driving in construction site of very difficult terrain while under heavy load (unpaved road); - Often driving on the road without gravel paving; - Extreme short distance transportation etc. Maintenance Maintenance precautions = Maintenance supplies Parts shall match the lubricants. Thus only what we tested and recommended shall be used. Every authorized Service Provider will provide suggestions to you. = Lubrication Refer to maintenance plan for lubrication and listed lubrication items. = Important bolt connections Important bolt connections shalll be checked frequently and retightened when necessary in accordance with different driving conditions such as driving on very bad road or construction site. Important parts of bolts connections include but not limited to: wheel, engine mounting, mounting parts (including sub-frame, lower swing arm, shock absorber, leaf spring and knuckle etc), steering unit, fuel tank, ABS, door cover stopper and hinge. Maintenance Maintenance plan Diesel engine vehicles No. Maintenance cycle/ General maintenance requirements for driving Maintenance items under normal conditions Mileage (km) First 5, 5,000 Every 15,000 Time (month) First 6 months | Every 12 months Replacing engine oil and oil filter ICheck for coolant level and cooling system pipeline and fill up coolant when necessary |Check for secure fuel system pipeline connection and fastening |Check for brake fluid level and brake system pipeline and fill up brake fluid when necessary ‘Check for reliable and effective fixings and retainers of front and rear suspension ICheck for power steering fluid level and hydraulic system pipeline and fill up hydraulic oll when necessary; Check for reliable and effective connections of steering track rod, ball jjoint and knuckle retaining bolts ~ [Chassis inspection: Check for each part, fixing, harness and pipeline of chassis are secured reliably and effectively with no disturbance; Check for chassis oil and water leakage V © ITyres (spare tyres included): Check for rear hub bearing and check for tyre pressure and wearing; Calibrate tyre pressure; Exchange tyre position when necessary; Check and tighten bolts to regulated torque © Check for complete and effective light signal, instrument display, electrical device functions [Check for battery level and charging and check and clear battery terminals, tightened when necessary (Check for damaged air bag surface and reliable and effective seat belt functions Maintenance No. Mileage (km) Maintenance cycle/ General maintenance requirements for driving First 5,000 Every 15,000 Maintenance items under normal conditions Time (month) First 6 months Every 12 months Check for reliable and effective AC pipeline connection and securing; Check for good AC 12 lrunctions y y 13 [Check for clamps at both ends of inter-cooler outlet pipe, and re-tighten them with a torque of| y J 14 \Road test: performance test Vv Vv 45 |Check for exhaust pipe connection is secured reliably and effectively and rubber shackles of y y lexhaust pipe are aged and broken 16 |Check for disturbance and damage of vacuum system pipeline v v 47 |Check for engine accessories belt, ifthe tensioning force does not meet the requirements, it y y is required to adjust it accordingly; If damaged, it is required to replace it with a new one 4g [Check for engine compartment hamess is secured reliably and effectively without disturbance| y y land damage 19 Check for front and rear brake shoes and parking brake clearance, as well as parking lever travel, adjust and replace when necessary 20 Check for transmission shaft universal joint gaiter is damaged 21 Check for wear and cracking of leaf spring end pad and lug bushing and replace when necessary 22 Check for transmission lubricant level and fill up when necessary 23 Read faults memory information of each system with after-sale diagnostic equipment 24 Check for reliable and effective operation of engine crankcase ventilation system Maintenance Mileage (km) No,| Maintenance cycle! General maintenance requirements for driving First 5,000 Every 15,000 | Maintenance items under normal conditions Time (month) | First 6 months | Every 12 months 25 |Check for brake pedal clearance and adjust when necessary 1 26 |Check for free travel of steering wheel and adjust when necessary 27 [Check for clutch pedal clearance and adjust when necessary 28 |Check for transmission gear lever clearance and adjust when necessary 29 \Clean and lubricate vehicle body accessories such as door lock, hinge and track 30 Replace AC ventilation system element 31 Replace air filter element 32 Replace fuel filter 33 Replace transmission lubricant, vehicles installed AISIN 5MT transmission: at first 5,000 km land every 4 years or 40,000 km (whichever comes the first) subsequently; vehicles installed ISAGW 6MT transmission: at first 5,000 km and every 80,000 km subsequently; vehicles installed DYMOS 6MT transmission: at first 4 years or 60,000 km (whichever comes the first) land every 120,000 km subsequently. To reduce the number of maintenances at service station| for the user, the subsequent maintenance interval can be appropriately ahead of schedule Special maintenance item 34 Replace brake fluid every 2 years or 65,000 km (whichever comes the first). To reduce the number of maintenances at service station for the user, the subsequent maintenance interval can be appropriately ahead of schedule Special maintenance item 35 Replace coolant every 4 years or 80,000 km (whichever comes the first). To reduce the number of maintenances at service station for the user, the subsequent maintenance interval ican be appropriately ahead of schedule Special maintenance item Maintenance No. Maintenance cycle/ General maintenance requirements for driving Maintenance items under normal conditions Mileage (km) First 5,000 Every 15,000 Time (month) First 6 months | Every 12 months 136 [Replace timing belt, tension and pulleys at first 5 years or 95,000 km (whichever comes the first) and every 5 years or 90,000 km (whichever comes the first) subsequently Special maintenance item Replace power steering fluid every 3 years or 80,000 km (whichever comes the first) 37 |To reduce the number of maintenances at service station for the user, the subsequent maintenance interval can be appropriately ahead of schedule Special maintenance item Replace front axle lubricant(for 4WD vehicles) and rear axle lubricant at first 5,000 km and 4g |every 3 years or 80,000 km (whichever comes the first) subsequently, To reduce the number lof maintenances at service station for the user, the subsequent maintenance interval can be lappropriately ahead of schedule Special maintenance item Replace automatic transmission lubricant (include changing automatic transmission oil 39 filter) at first 96,000 km and every 100,000 km subsequently. To reduce the number of maintenances at service station for the user, the subsequent maintenance interval can be lappropriately ahead of schedule Special maintenance item Replace thansfer lubricating oil every 80,000 km (It is suitable for vehicle equipped with 40 |thansfer). To reduce the number of maintenances at service station for the user, the |subsequent maintenance interval can be appropriately ahead of schedule Special maintenance item Note: 1. The maintenance content of this table is applicable to our company manufactured series vehicle and selection of maintenance| items shall depend on vehicle features. 2. The maintenance interval of air filter element and AC ventilation system element shall be shortened for vehicles running in the| environment full of dust. 3. Tire rotation every 5,000 to 10,000 km based on tire wear and then tire pressure correction. 4. For vehicles subject to long-term idle operation such as troop carrier and police car, the vehicle OAD(Overrunning Alternator] Decoupler) shall have the replacement time shortened, for example, replaced when the vehicle running at idle for 2,000 hours. 10 Maintenance 20L4E gasoline engine vehicles No. Maintenance cycle/ General maintenance requirements for driving Maintenance items under normal conditions Mileage (km) First 5,000 Every 10,000 Time (month) First 6 months _| Every 12 months Replacing engine oil, oil filter, seal ring of oil filter; When the vehicle mileage is more than 17,500 km, please check the dipstick, if the oil level is below the “MIN” mark, please refill q y ICheck for coolant level and cooling system pipeline and fill up coolant when necessary v v |Check for secure fuel system pipeline connection and fastening v ICheck for brake fluid level and brake system pipeline and fill up brake fluid when necessary q alalofr Check for reliable and effective fixings and retainers of front and rear suspension ICheck for power steering fluid level and hydraulic system pipeline and fill up hydraulic oll when necessary; Check for reliable and effective connections of steering track rod, ball ljoint and knuckle retaining bolts [Chassis inspection: Check for each part, fixing, harness and pipeline of chassis are secured reliably and effectively with no disturbance; Check for chassis oil and water leakage ITyres (spare tyres included): Check for rear hub bearing and check for tyre pressure and wearing; Calibrate tyre pressure; Exchange tyre position when necessary; Check and tighten bolts to regulated torque qv |Check for complete and effective light signal, instrument display, electrical device functions 10 |Check for battery level and charging and check and clear battery terminals, tightened when necessary 1 \Check for damaged air bag surface and reliable and effective seat belt functions " Maintenance No. Mileage (km) Maintenance cycle/ General maintenance requirements for driving First 5,000 Every 10,000 Maintenance items under normal conditions Time (month) First 6 months Every 12 months Check for reliable and effective AC pipeline connection and securing; Check for good AC 12 lrunctions y y 13 [Check for clamps at both ends of inter-cooler outlet pipe, and re-tighten them with a torque of| y J 14 \Road test: performance test V Vv 45 |Check for exhaust pipe connection is secured reliably and effectively and rubber shackles of y y lexhaust pipe are aged and broken 16 |Check for disturbance and damage of vacuum system pipeline v v 47 |Check for engine accessories belt, if the tensioning force does not meet the requirements, it y y is required to adjust it accordingly; If damaged, it is required to replace it with a new one 4g [Check for engine compartment hamess is secured reliably and effectively without disturbance| y y land damage 19 Check for front and rear brake shoes and parking brake clearance, as well as parking lever travel, adjust and replace when necessary 20 Check for transmission shaft universal joint gaiter is damaged 21 Check for wear and cracking of leaf spring end pad and lug bushing and replace when necessary 22 Check for transmission lubricant level and fill up when necessary 23 Read faults memory information of each system with after-sale diagnostic equipment 24 Check for reliable and effective operation of engine crankcase ventilation system 12 Maintenance Mileage (km) No,| Maintenance cycle! General maintenance requirements for driving First 5,000 Every 10,000 ‘| Maintenance items under normal conditions Time (month) | First 6 months | Every 12 months 25 |Check for brake pedal clearance and adjust when necessary 1 26 |Check for free travel of steering wheel and adjust when necessary 27 [Check for clutch pedal clearance and adjust when necessary 28 |Check for transmission gear lever clearance and adjust when necessary 29 \Clean and lubricate vehicle body accessories such as door lock, hinge and track 30 Replace AC ventilation system element at first 15,000 km and every 20,000 km subsequently} Special maintenance item 31 Replace air filter element at first 15,000 km and every 20,000 km subsequently Special maintenance item 32 Replace fuel filter at first 35,000 km and every 40,000 km subsequently Special maintenance item 33 Replace transmission lubricant, vehicles installed SAGW 6MT transmission: at first 5,000 km and every 80,000 km subsequently; vehicles installed DYMOS 6MT transmission: at first '4 years or 60,000 km (whichever comes the first) and every 120,000 km subsequently. ‘To reduce the number of maintenances at service station for the user, the subsequent maintenance interval can be appropriately ahead of schedule Special maintenance item 34 Replace brake fluid every 2 years or 65,000 km (whichever comes the first). To reduce ithe number of maintenances at service station for the user, the subsequent maintenance interval can be appropriately ahead of schedule Special maintenance item 35 Replace coolant every 2 years or 65,000 km (whichever comes the first). To reduce the number of maintenances at service station for the user, the subsequent maintenance interval ican be appropriately ahead of schedule Special maintenance item 13 Maintenance Maintenance cycle/ No. Maintenance items General maintenance requirements for driving under normal conditions Mileage (km) First 5,000 Every 10,000 Time (month) First 6 months Every 12 months Replace engine accessories belt every 3 years or 80,000 km (whichever comes the first). 36 |To reduce the number of maintenances at service station for the user, the subsequent maintenance interval can be appropriately ahead of schedule Special maintenance item 37 Replace front axle lubricant(for 4WD vehicles) and rear axle lubricant at first 5,000 km and levery 3 years or 80,000 km (whichever comes the first) subsequently Special maintenance item 3g [Replace automatic transmission lubricant (include changing automatic transmission oil filter) iat first 95,000 km and every 100,000 km subsequently Special maintenance item 39 [Replace spark plug at first 25,000 km and every 30,000 km subsequently Special maintenance item 40 |Replace thansfer lubricating oil at first 75,000 km and every 80,000 km subsequently (It is |suitable for vehicle equipped with thansfer) Special maintenance item Note: 1. The maintenance content of this table is applicable to our company manufactured series vehicle and selection of maintenance items shall depend on vehicle features. 2. The maintenance interval of air filter element and AC ventilation system element shall be shortened for vehicles running in the| environment full of dust. 3. Tire rotation every 5,000 to 10,000 km based on tire wear and then tire pressure correction. 4. For vehicles subject to long-term idle operation such as troop carrier and police car, the vehicle OAD(Overrunning Alternator] Decoupler) shall have the replacement time shortened, for example, replaced when the vehicle running at idle for 2,000 hours. 14 Maintenance 4G69S4N gasoline engine vehicles No. Maintenance cycle/ General maintenance requirements for driving Maintenance items under normal conditions Mileage (km) First 5, 5,000 Every 5,000 Time (month) First 6 months _| Every 12 months Replacing engine oll and oil filter v y ICheck for coolant level and cooling system pipeline and fill up coolant when necessary Vv |Check for secure fuel system pipeline connection and fastening qv ICheck for brake fluid level and brake system pipeline and fill up brake fluid when necessary qv alalolr ICheck for reliable and effective fixings and retainers of front and rear suspension v [Check for power steering fluid level and hydraulic system pipeline and fill up hydraulic oll when necessary; Check for reliable and effective connections of steering track rod, ball jjoint and knuckle retaining bolts [Chassis inspection: Check for each part, fixing, harness and pipeline of chassis are secured reliably and effectively with no disturbance; Check for chassis oil and water leakage HTyres (spare tyres included): Check for rear hub bearing and check for tyre pressure and wearing; Calibrate tyre pressure; Exchange tyre position when necessary; Check and tighten bolts to regulated torque qv |Check for complete and effective light signal, instrument display, electrical device functions 10 \Check for battery level and charging and check and clear battery terminals, tightened when necessary 1 (Check for damaged air bag surface and reliable and effective seat belt functions 12 ICheck for reliable and effective AC pipeline connection and securing; Check for good AC functions 15 Maintenance No. Mileage (km) Maintenance cycle/ General maintenance requirements for driving First 5,000 Every 5,000 Maintenance items under normal conditions Time (month) First 6 months Every 12 months 13, Check for clamps at both ends of inter-cooler outlet pipe, and re-tighten them with a torque off 5Nm V 14 Road test: performance test 15 Check for exhaust pipe connection is secured reliably and effectively and rubber shackles of lexhaust pipe are aged and broken 16 Check for disturbance and damage of vacuum system pipeline 17 Check for engine accessories bell, if the tensioning force does not meet the requirements, it is required to adjust it accordingly; If damaged, it is required to replace it with a new one 18 Check for engine compartment harness is secured reliably and effectively without disturbance land damage 19 Check for front and rear brake shoes and parking brake clearance, as well as parking lever travel, adjust and replace when necessary 20 Check for transmission shaft universal joint gaiter is damaged 21 Check for wear and cracking of leaf spring end pad and lug bushing and replace when necessary 22 Check for transmission lubricant level and fill up when necessary 23 Read faults memory information of each system with after-sale diagnostic equipment 24 Check for reliable and effective operation of engine crankcase ventilation system 25 Check for brake pedal clearance and adjust when necessary 16 Maintenance Mileage (km) No,| Maintenance cycle/ General maintenance requirements for driving First 5,000 Every 5,000 Maintenance items under normal conditions Time (month) First 6 months | Every 12 months | 26 |Check for free travel of steering wheel and adjust when necessary v 27 |Check for clutch pedal clearance and adjust when necessary 28 |Check for transmission gear lever clearance and adjust when necessary v 29 |Clean and lubricate vehicle body accessories such as door lock, hinge and track v 30 |Replace AC ventilation system element every 20,000 km Special maintenance item 31 [Replace air filter element every 20,000 km Special maintenance item 32 |Replace fuel filter every 40,000 km Special maintenance item 33 Replace transmission lubricant, vehicles installed SAGW SMT transmission: at frst 5,000 km] 6. a1 maintenance item 34 [Replace brake fluid every 2 years or 65,000 km (whichever comes the first) Special maintenance item 35 [Replace coolant every 2 years or 65,000 km (whichever comes the first) Special maintenance item 36 [Replace engine accessories belt every 3 years or 80,000 km (whichever comes the first) Special maintenance item 37 [Replace timing toothed belt every 80,000 km Special maintenance item 38 [Replace power steering fluid every 3 years or 80,000 km (whichever comes the first) Special maintenance item FEE oe SS eee a fa Saab tat 5,000 kr and] Speci maninane tm 40 [Replace spark plug every 40,000 km (check each time maintenance after 20,000 km since Special maintenance item ithe last replace time) Maintenance Mileage (km) No,| Maintenance cycle! General maintenance requirements for driving First 5,000 Every 5,000 Maintenance items under normal conditions Time (month) First 6 months | Every 12 months a“ Replace thansfer lubricating oil every 80,000 km (It is suitable for vehicle equipped with Special maintenance item Note: 4. The maintenance content of this table is applicable to our company manufactured series vehicle and selection of maintenance items shall depend on vehicle features. 2. The maintenance interval of air filter element and AC ventilation system element shall be shortened for vehicles running in the) environment full of dust. 3. Tire rotation every 5,000 to 10,000 km based on tire wear and then tire pressure correction. 4. For vehicles subject to long-term idle operation such as troop carrier and police car, the vehicle OAD(Overrunning Alternator] Decoupler) shall have the replacement time shortened, for example, replaced when the vehicle running at idle for 2,000 hours. 18

You might also like