Professional Documents
Culture Documents
Are you getting SOLIDWORKS warning messages about your auto recovery folder and don’t
know how to correct it? Fear not, this guide will show you what this means and how to fix it.
This warning message, Figure 1, is SOLIDWORKS’ core functionality, regardless of what add-in
or what product you are using inside of it. It pops up when SOLIDWORKS boots up or when you
load a file.
It is a specific message geared to ensure the auto-recover folder exists, there is enough storage
on the drive where that folder is located, and you have written access to it.
Figure 1: ‘The specified auto-recover folder does not exist and cannot be created. The disk
might be full or permissions might be restricted. Please correct the problem or create a new
auto-recover folder in an available location.
Go to Tools > Options > Backup/Recover > Auto Recover > Auto-recover folder. See Figure 2.
Make note of the Auto-recover folder location and use Windows Explorer to browse to that
folder. If you cannot find the Auto-recover folder, there is the problem. Simply designate a new
folder by clicking the browse-to icon in the Auto-recover folder settings. See Figure 3.
Figure 2: Auto-recover options in System Options
Go to the Security settings for that folder (right-click the folder and choose
properties) and ensure that your user profile has Write access. You might have to
get with your IT department for this. See Figure 4.
Browse to the drive in Windows Explorer and right-click > Properties and check the
Free Space. If your drive has run out of storage, designate a new Auto-recover
folder in a drive with sufficient free space. See Figure 5.
This simple test ensures the SOLIDWORKS Auto-recover functionality works correctly.
If you have tried the steps above and the file is not generating in the Auto-recover folder, try
these steps next:
Ensure the part is in a ‘dirty’ state. See Figure 6. SOLIDWORKS will NOT generate a new
Auto-recover file if it sees that the file is identical to its last save. Do a force-rebuild or
change the model, DO NOT save, and wait 1 minute to force the file creation.
Ensure that a Windows function, such as UAC (User Access Control), is not meddling
with the folder. To test this, open Windows Explorer and create a new folder on the C:
drive (C:\Test for example). Then change the Auto-recover folder location to this folder.
See Figure 3. Try the steps above to test functionality again.
If all else fails, try to open SOLIDWORKS in a “safe” mode, using the SOLIDWORKS RX
tool, to rule out corruption with the settings. If after opening SOLIDWORKS, the Auto-
recover functionality works, then you can safely say that it is a corruption in the settings.
For that, you can reset the SOLIDWORKS registry or do a clean uninstall.
Figure 6: Asterix showing a file in a dirty state to force creation of Auto-recover file