Professional Documents
Culture Documents
(Generic Tractor)
Important You will save time and prevent wrong installation of components by
closely following these step-by-step instructions. If you have
Notices questions, call Ag Leader Technology at 515-232-5363 Ext 1.
Common The following are common components related to all ISOBUS Retrofit
Kit (Generic Tractor) installations.
Components
Component
and Cable
Layout
Safety CAUTION: Turn off machine and wait for all motion to stop before
starting work. Set parking brake.
Notices
CAUTION: Be sure to wear proper eye protection when using any
power tools, such as when drilling any mounting holes.
NOTE: Be sure to follow the alignment keys on the plugs and the
receptacles carefully. Do not use excessive force when mating
connectors.
Step-by-Step NOTE: If a display has been previously installed, this section may
instructions for be skipped.
installing the
Display 1. Attach the square RAM Display Mount, PN: 4000280 to the back of
the Display using four 6mm Phillips pan head screws and lock
washers provided in the RAM Mount Kit.
3. Take the RAM Base Mount, PN: 4000187, and use the 13/32” drill
and self-tapping screws as needed to secure the Base Mount.
Installing the
Parts required for procedure (Pick One):
Display Power Cable - Display/Guidance/High Current Power (5 FT) PN: 4002016-5
Cable Cable - Display/Guidance/High Current Power (12 FT) PN: 4002016-12
Cable - Display/Guidance/High Current Power (22 FT) PN: 4002016-22
Cable - Display/Guidance Power (5 FT) PN: 4002026-5
Cable - Display/Guidance Power (12 FT) PN: 4002026-12
Cable - Display/Guidance Power (15 FT) PN: 4002026-15
Cable - Display/Guidance Power (22 FT) PN: 4002026-22
NOTE: A Power Cable from the list above is required for all installations. If
a display and power cable has been previously installed, this section may
be skipped.
NOTE: Do not connect power cable to the battery, this will be done as a
last step along with the power connection for the ISOBUS/IBBC Power
Relay Assembly
Installing the
From ISOBUS Retrofit Kit (Generic Tractor)
ISOBUS (1) ISOBUS/Power Control Ext. Cable (10FT) PN: 4002585-10
Display Cable (1) ISOBUS Active Termination Cable PN: 4002587
3. Connect the 3 pin weather pack of the ISOBUS Display Cable, PN:
4002506-12 to 3 pin weather pack of Power Display/Guidance
Cable, PN: 4002026-15.
BLACK
(NEGATIVE)
RED
(POSITIVE)
7. Route the ISOBUS Battery Cable, PN: 4002865-X along the chassis
to the battery away from heat sources and mechanical linkage, use
provided cable ties to secure cable away from any moving parts.
8. Connect the Display Power Cable and the ISOBUS Battery Cable,
PN: 4002865-X to the battery.