3. What is internal RAM memory of 8051 microprocessor?
1. 32 bytes 2. 64 bytes 3. 128 bytes 4. 256 bytes 4. Register that is used to holds the memory address of the next instruction to be executed is 1. Program Memory 2. Program Counter 3. Control Unit 4. Instruction decoder 5. Which register is used to store the output generated by ALU? 1. Special Function Register 2. Timer Register 3. Accumulator 4. Stack Pointer 6. The 8051 microprocessor has ________ parallel I/O ports. 7. Which of the following is the default value of stack once after the system undergoes the reset condition? 1. 08H 2. 09H 3. 00H 4. 07H 8. 9.
10. The register that can be used as a scratch pad is
a) Accumulator b) B register c) Data register d) Accumulator and B register 11. The registers that contain the status information is a) control registers b) instruction registers c) program status word d) all of the mentioned 12. The register that is used for accessing external data memory is a) DPH b) DPL c) DPTR d) NONE 13. If RS1=1, RS0=0, then the register bank selected is a) register bank 0 b) register bank 1 c) register bank 2 d) register bank 3 14. The pulses at T0 or T1 pin are counted in a) timer mode b) counter mode c) idle mode d) power down mode 15. Read-only memory holds _____ kb of storage in 8051. a) 2 b) 4 c) 6 d) 8 16. The chip crystal oscillator holds a frequency of ____ MHz in 8051. a) 6 b) 12 c) 18 d) 24 17. Pin 9 represents ______ pin in 8051 microcontroller. a. Start b. Reset c. Ground d. None Of These 18. Expand PSEN Full form _______________________________________ 19. Expand EA full form _____________________________ 20. Expand ALE full form________________________________ 21. Using port 0, the lower sequence _________________ signals are multiplied. 22. Expand PSW full form ________________________ 23. Data point register holds ____ bit address. 24. PSW register is also called as _____ register? a) Program b) Shift c) Flag d) Right
25. The ALU performs ______________
a) Arithmetic operations only b) Logical operations only c) Both a and b d) None of the above 26. How many oscillator periods defines the machine cycle a) 2 oscillator periods b) 4 oscillator periods c) 6 oscillator periods d) 12 oscillator periods 27. Draw the Power on Reset Circuit.
28. Write the Alternative functions of 8051.
29. Match the Following.
P0 - 90H P1 - 0B0H P2 - 80H P3 - 0A0H 30. Match the Following. General Purpose Register - 2 Special Function Register - 8 16 Bit Register - 21 Register in single Bank - 32