Professional Documents
Culture Documents
Shuttle
The shuttle shall be made of natural and/ or synthetic materials. The flight qualities
of the shuttle, regardless of the material used, should be similar to those of a natural
feathered shuttle with a cork base covered in a thin coating of leather. Feathered shuttle
is a type of shuttle that have 16 feathers of goose or duck that is fixed in the cork (made
from the bark of a cork tree). The shuttle should be between 4.74 and 5.50 grams in
weight. On the other hand, non feathered shuttle is made up of of synthetic materials.
The measurements and weight of a non feathered shuttle should conforme with the laws.
Insert Shuttlecock
picture here with label
Racket
The racket's total length and width must not exceed 68cm and 23cm,
respectively. The handle is the part of the racket that a player holds in his or her hand.
While the stringed area is the part of the racket with which a player is supposed to hit the
shuttle. Moreover, it should be flat and consist of a pattern of crossing strings that are
alternately interlaced or bonded at their intersection points. The head is the part of the
racket frame in which the stringed area is attached. The shaft connects the handle of
the racket frame to the head while the throat is the part that connects the shaft to the
head.
Court
The court shall be a rectangle marked out with lines 4 cm wide as shown in the
diagram below. The full dimension of the court shall be 13.4 m long x 6.1 m wide and the
diagonal length of full court shall be 14.723 m.
Two sidelines for doubles and two sidelines for singles is marked 46 cm away from
each other with a measurement of 13. 4m. Two endlines shall be drawn at the end of
sidelines with a measurement of 6.1 m and two long service lines is drawn 76 cm away
from each endlines. 3.96 m from each long service lines shall mark the short service line.
The center line shall be drawn at the center of the court; 3.05 m away from each sidelines
for doubles. The line starts at the endline up to the short service line of each side of the
court.
Centerline
Net
Posts
Centerline
Net
The net must be made of fine dark-colored cord with a consistent thickness and a
mesh size of not less than l.5 cm and not more than 2 cmm. The net must be at least 6.1
m wide and 76 cm depth. It shall be be suspended from the top of the posts. The height
of the net at each sidelines for doubles should be 1.55 m and 1.524 m at the center of
the court for both men and women.