ASME BPVCY-2021, ARTICLE 6
Table T-621.1
Requirements of a Liquid Penetrant Examination Procedure
‘onesental
identcacon oad any chang in peor fanly group of ponent mates adding x
Surfce preparation (flehing and cleaning Including type of cleaning slvent) x
Method of removing excess surface penetrant x
‘ne for hydrophilic enulsiers
{yrophe eser canesntration in spray appestons x
Method of aptying developer x
Doses peeant ee ma tomeats x
incre in developer al ae iatrpretation Tins) x
Minimum ihe mens x
Surtace ener outtde40# to 125 (SC SI) ar previously aiid x
Performance demonstration whe required x
Materals, shape, or snes to e examined andthe extent of examination x
NOTE Content srices or eaninaonsrqurdinT-650 TECHNIQUE
” _— 7-651 TECHNIQUES ey
1-643 DRYING AFTER PREPARATION Either a color contrast (visible) penetrant or a uores-
‘After cleaning, drying ofthe surfaces to be examined cent penetrant shall be used with one of the following
shall be accomplished by normal evaporation or with three penetrant techniques:
forced hot oF cold air. A minimum period of time shall (@) water washable
be established to ensure thatthe cleaning solution has (2) post-emulsifying
evaporated prior to application of the penetrant. {(c) solvent removable
Table T-621.3
Minimum and Maximum Time Limits for Steps in Penetrant Examination Procedures
Deying afer preparation (F643) x
Penetrant del (7672) x x
Penetant removal water washable/slvent removable (1-6731/1-6733)
Penetrant removal with lipophilic emulsifier (1-673.2(2] x x
Penetant removal with hydrople emulser(1-5732(0)}
Water immersion or spray poscvinse x
Doving afer pentran removal (7675)
Solvent eemoval penetrants
Developer application (7-57
Developing and interpretation sim (7.675. and':676) x
2ar