Professional Documents
Culture Documents
180 35 30 25 20 15 10 5 0
>333 km/hr >207 mph 170 10
150 30
Front 1048 N 236 lbs 140 40
Side 510 N 115 lbs 130 50
120 60
110 70
Antenna consisting of aluminum alloy with brass feed- 100 90 80
-170 -10
160 20
Impedance 50Ω 150 30
3) 140 40 Amphenol Antel’s
Connector NE, E-DIN 130 50 Exclusive 3T (True
1) 120 60
VSWR ≤1.4:1 110
100 90 80
70 Transmission Line
Technology)
Polarization Slant ± 45° Vertical Antenna Design:
1)
Isolation Between Ports < -30 dB
1)
• Watercut brass feedline assembly for
Gain 16 dBd Radiation patterns for all antennas consistent performance.
2) are measured with the antenna • Unique feedline design eliminates the
Power Rating 500 W need for conventional solder joints in
1)
mounted on a fiberglass pole. the signal path.
Half Power Angle • A non-collinear system with access to
H-Plane 63° Mounting on a metal pole will every radiating element for broad band-
width and superior performance.
typically improve the Front-to- • Air as insulation for virtually no internal
E-Plane 7°
Back Ratio. signal loss.
1)
Electrical Downtilt 5°
1) Every Amphenol Antel antenna is under a
Null Fill 5% five-year limited warranty for repair or re-
Lightning Protection Direct Ground placement.
*Also available up to 960 MHz. Consult your Antenna available with center-fed
sales director for more information. connector only.
Patented Dipole Design: U.S. Patent No. 6,608,600 B2
1)
Typical Values
2)
3)
Power Rating limited by connector only. CF Denotes a Center-Fed
NE indicates an elongated N Connector.
E-DIN indicates an elongated DIN Connector. Connector.
4)
The antenna weight listed above does not include the
bracket weight.
Improvements to mechanical and/or electrical performance of the
antenna may be made without notice.
806-900 MHz
1300 Capital Drive Rockford, IL 61109 Toll-Free (888) 417-9562 Tel. (815) 399-0001 Revision Date: 6/3/04
Fax. (815) 399-0156 Email: antel@antelinc.com www.antelinc.com