A person or organization who has direct contract SUBCONTRACTOR
with a prime contractor to perform a portion of the work at the site. A person trained and experienced in the design of PME mechanical system for buildings. A material property which enables it to undergo DUCTILITY plastic deformation after being stressed beyond the elastic limit and before rupturing. A person trained and experienced in the design of ECE electronics and communication system for buildings. A measure if material’s resistance to deformation STIFFNESS when stressed within elastic range. A material property that enables it to resist HARDNESS deformation by compression, indentation, or penetration. A combination of two or more materials to form COMPOSITE a better material. A _______ engineer is trained in the design of CIVIL static structures such as buildings, roads, tunnels, and bridges and the control of water and its contaminant. A person professionally and academically ARCHITECT qualified, registered and licensed under R.A. No. 9266. A ______ engineer is a person trained to conduct GEODETIC surveys on lands, either flat or with varying slopes, and locate global positions of points.
TEST II.
Alburnum is a younger, softer, living portion of True
wood. S2S belongs to dressed lumber. True Yard Lumber is a softwood lumber intended for True general building purposes, including boards, dimension lumber and timbers. There are 3 classification of Philippine wood. False Cross Band is a layer of veneer immediately True adjacent to and at right angles to the face plies in a plywood panel. Tampered Hardboard is a hardboard False impregnated with a drying oil or other oxidizing resin and baked to improve resin and baked to improve its hardness and moisture resistance. Flat Grain is a wood grain resulting from plain- False sawing, having the annual rings forming an angle of more than 45 degrees with the board faces of a piece. Bow is a warp resulting from the turning edges of False a wood piece in opposite directions. Course Grain is a wood grain having large pores. False Radial is a wood shrinkage perpendicular to the True grain, across the growth rings.
TEST III.
A nailing technique used to secure by nailing in Blind Nail
such a way that nail heads are not visible on the face of the work. A U-shaped fastener secure by a bolt or pin Clevis through holes in the end of the two arms. A finished cement that develops low or zero Sticky Cement workability during or after storage in Silos. A deposit of salts formed on a surface. Efflorescence A U-shaped piece of metal or heavy wire with Staple pointed ends, driven into a surface to secure sheet material or to hold a hasp, pin, or bolt. Tongued Miter
A cement reacts with water. Hydraulic Cement
It is overhead cover. Ceiling An anchor bolt having a split end to receive a Fox Bolt foxtail wedge as it is screwed into a blind hole. Butterfly Wedge
Ordinary Lap Joint
The ratio between total volume to volume of Porosity
voids. Finger Joint
It carries partial load from floor joist. End Girder
The output for combining cement, water, fine Concrete aggregate and coarse aggregate. Concrete placing before tension. Post Tension Other term for Cast-in-place. IN SITU Dovetail Halving
It is the top most portion of wall frame. Top Plate
A screw or rivet head having a cylindrical shape Panhead with a rounded shoulder. Fish Joint
A concrete placed and cured other thaan where Precast
is it to be installed, usually prestressed. The horizontal Layering with light materials Stratification above and heavy materials below cause by excessively wet mixture or over vibration. A screw having a ring-shaped head. Screw Eye A fused mass of incombustible material resulting Clinker from heating in a klin or the burning of coal.
TEST IV.
Non-Hydraulic Cement reacts with ______ Carbon Dioxide
Cyclopean requires fine aggregate and ____ Boulder concrete The first reinforced concrete bridge is ______ Alvord Lake Bridge The first high-rise reinforce concrete building is Ingalls Building ____ ______ Silicate is the compound responsible for Tricalcium the Hardening or Early Strength Gain of concrete. The patent for reinforced concrete using bars was Joseph Monier issued to _____ ____ water is added to the concrete mix means More lesser strength. The size of a fine aggregate is from #4 - #____ 200 Concrete is ____ against tension. Weak Concrete is ____ against compression. Strong TEST V.
Wet Covering Curing
90 Degree Bend Bar Works Yoke Form Works Slump Test Casting Use of Trowel Finishing Dry Mix Concrete Finishing Batching Plant Mixing Adding Additives Mixing Exposed Aggregates Finishing Immersion Curing Settling Period Curing Adding Cement Mixing Vibration Consolidation Shore Form Works Spreader Form Works Direct Pouring Casting Bar Installation Bar Works Beton Brut Finishing Forms Form Works Tamping Consolidation