Professional Documents
Culture Documents
SCT 1050 v11
SCT 1050 v11
SCT 1050 v11
www.sennetech.net
Sennetech, Inc. 6455 W. Bath Rd. Perry, MI 48872 U.S.A. Ph (517) 675-1150 Fax (517) 675-1151
The SCT-1050 is a Javelin to Pelco control code translator designed to permit control of Pelco
cameras from Javelin controllers. It receives Javelin RS-232 commands and re-transmits them as
Pelco RS-422 commands. There are four independent Pelco outputs.
Internal switches are used to configure the operation of the code translator.
The input can be Javelin code for either JO308 receivers or JO208 receivers.
The code translator can be configured for groups of 32 Pelco cameras, or for groups of 256 Pelco
cameras.
Input and output connections are made with mating screw terminal connectors. Front panel LEDs
indicate status of power, receive, and transmit.
There is an optional 19" rack mount panel (one rack unit high).
SPECIFICATIONS
SW3-1
PELCO CODE TYPE
ON: "P" CODE CN1 CN7 CN6 CN5 CN4 CN2
U2
SW3-3
"P" CODE PARITY
ON: EVEN PARITY U1
OFF: NO PARITY
U6
(Note: Set to even
parity for Pelco
On
CM9760CXTA) 12345678
Off
SW1
4
Configuration notes
Groups of 32 are useful for Pelco receivers that cannot accept an address higher than 32, such as
older Spectra Domes using "P" code, or a CM9760CXT coaxitron code generator.
For groups of 32, the maximum usable Javelin address is 256. For groups of 256, the maximum
usable Javelin address is 2048.
FRONT PANEL
Power Rx Tx
CODE TRANSLATOR
BACK PANEL
JAVELIN PELCO DATA OUTPUTS POWER
RS-232 9V to 15V
Rx Tx Com S S S S AC or DC
To install the case on the rack mount frame, remove the front panel and the plastic bezel. The rack
mount frame takes the place of the bezel as shown below.
6
OPERATION
Javelin Pan, Tilt, Zoom, Focus, and Iris commands are converted directly to equivalent Pelco
commands.
Presets:
Javelin preset commands 1~13 are converted directly to Pelco preset commands.
Other commands are converted according to the following table:
Patterns:
Prgm [14] Start Pattern Recording
Pshot [14] End Pattern Recording
Pshot [15] Run Recorded Pattern