Professional Documents
Culture Documents
Fuctions
SPD Speed
ODO Total cycling distance
DSTOne-pass cycling distance
MXSMaximum speed
AVSAverage speed
TMOne-pass cycling time
CLK Clock
SCANAutomatic Cycleplay
BACKLIGHT
SW Stop-watch
CDDCount-down distance
CDTCount-down time
CALConsumed calorie
FATConsumed fat
TEMTemperture
Alter For power shortage
Power saving
‘+’& ‘-‘ Speed comparing
Upkeep reminding
KM/hr M/hr setting
Wheel perimeter setting
Total distance initial value setting
Cycling date sampling
Automotive wake-up
Installation of Battery
Open the battery lid with a coin. Put in a 3V CR2032 Battery. ( Positive pole upwards)
Install the Inductor on the front fork ( Same side as the magnet),Fix the inductor with the
complimentary armor tape, twine the wire on the handlebar.(Fix with armor
tape) ,Adjust the position between the magnet and inductor, make the distance around
1.5mm.(The closer ,the Better) .When fix the magnet, never let the magnet towards the
centre of inductor, make the magnet towards to the upside or downside of the inductor.
1. Record the size marked on the wheel , find out the perimeter by referring to the
follow chart
2. Draw a spot on the wheel, then push the bike, The distance is the wheel perimeter when
the spot runs a circle.
Press the right button to change the number, Press left button to confirm and set the next
parameter.
Weight setting
All initial setting have completed till this step, Your cycling
date will be recorded
Function switching
Press right button to switch the mode.
ODO – DST – MEX – AVS – TM – SW – CDD – CDT – CAL – FAT – TEM – SCAN - CLOCK
Press left button 3 seconds to set 12/24hr mode. Press left button
to switch 12hr/24hr. Press right button to set the hour, press right
button to adjust the number. Left button adjust the number. Right
button confirm. Press right button to view the ODO.
The total distance when (TM)One-pass cycling time start. Press left
button 3 second to delete the DST date. Meanwhile the MXS,AVS
& TM date will be deleted. Press right button to view the MXS.
SW (Stop-watch)
Press left button to start. Press left button again to stop. Press right
button to delete .Press left button 3 seconds to lock at the SW page.
Press left button 3 seconds again to unlock. Press the right button
to view CDD.
(TEM) Temperature
Screen will shows DST, MXS ,AVS ,TM successively. Press right button
to end the SCAN and enter Clock mode.
If there is no input within 300 seconds. The screen will turn off.(show
the clock only). The screen will turn on when receive any input or
cycling signal.
Press left button at any mode, the computer will enter cycling date sampling. The bottom
of the screen will show flickering cycling time(TM ), press right button to view sampled
cycling distance(DST) ,cycling time(TM ), cycling average speed (AVS), Maximum speed
(MXS).
Press left button again to quit sampling.
Press both left and right button 3 seconds to reset distance unit(KM/M) , wheel perimeter,
weight & upkeep remind distance. The original date will be kept.
Current speed
The current speed will show at the top position.
Speed comparing
‘+’ means current speed exceed average speed, ‘--’ means current
speed is under average speed.
Backlight
The backlight will turn on when you press any button 18:00 to 6:00.
Malfunction Reasons
Speed show ’0’ when cycling 1.The distance or install position has problem
between magnet and inductor;
2.Power shortage
Wrong Speed value wheel perimeter is incorrect
Screen display slowly-react Computer work under 0°
Blank screen Expose under light for a long time
Screen unclear Power shortage or battery poor contact