Professional Documents
Culture Documents
8 sunset time
Before initial use, plug the timer in for at least 30 minutes to charge the
internal battery. After the screen displays, the unit is ready for programming. a. Press the button again to set the Astronomic function.
1. Reset Press button or to adjust three different areas to
Before programming, all settings should be reset. The reset button is your current location
identified by “RESET”. Use a paper clip or ball point to stick it.
1. NORTH: 2. CENTRAL:3. SOUTH:
Thank you for your purchase. 2. Set the Current date
Please contact us if you have any problem. a. Press the button to set the current year.
Email: support@dewenwils.com Press or button to adjust the flashing number.
Please attach your User Name or Order ID so that b. Press the button again to set the month.
we can assist you better. Press button or to adjust the number from 01 to 12.
b. Set the Sunrise time reception, which can be determined by turning the equipment off and on,
Mode Setting Display Function the user is encouraged to try to correct the interference by one or more of
Press the button again to adjust the Sunrise time.
Press or button to adjust ±2 hours, the following measures:
Press back to current Sunrise time. always on • Reorient or relocate the receiving antenna.
ON button
If AM twinkling it means that setting Sunrise time. • Increase the separation between the equipment and the receiver.
c. Set the sunset time • Connect the equipment into an outlet on a circuit different from that to
Press the button again to adjust the Sunset time. always off which the receiver is connected.
OFF button • Consult the dealer or an experienced radio/TV technician for help.
Press or button to adjust ±2 hours,
Press back to current Sunset time.
If PM twinkling it means that setting Sunset time button and Timer is ON currently This device complies with Part 15 of the FCC Rules. Operation is subject to
then button and ON/OFF program the following two conditions:
6. Programming of Switching Times (On/Off) AUTO ON is activated (1) this device may not cause interference, and(2) this device must accept
Note: in the process, press the will clear the current setting. Timer is OFF currently any interference, including interference that may cause undesired operation
button and and ON/OFF program of the device.
then button is activated
AUTO OFF
Press the button again to set event 1 ON. RDM is ON currently FCC Caution: Any changes or modifications not expressly approved by the
a. Set the Day button and party responsible for compliance could void the user's authority to operate
then button and ON/OFF program
Press the or button repeatedly until the display shows the RDM ON is activated this equipment.
DAY(s) you want.
b. Set the time RDM is OFF currently
button and
Press the button again, and then press the or button to set and ON/OFF program
RDM OFF then button
hours. is activated
There are 2 modes for you to choose: Dewenwils warrants this product to be free from defects in material and
a) 12-hour clock AM/PM workmanship for a period of one year from the date of purchase. Warranty
Press the or button to set the hours. is void if damage is caused by misuse or improper installation. Please
Input Voltage: 120VAC, 60Hz contact us if you have any questions.
Press to set minutes
Max Power Rating: 15A Email: support@dewenwils.com
Press the or button to set the minutes.
Cord: 6 ft SJT 14/3C Our dedicated customer service team will get back to you within 24 hours.
b) Sunrise/Sunset
Press the or button for a 24 hours
cycle to enter the Sunrise/Sunset mode.