F-SE TIGER Il QUICK REFERENCE CHECKLIST - NORMAL PROCEDURES.
FOR COMPLETE INFORMATION REFER TOT.0. 1F5E1
PREFLIGHT CHECK
Ground Crew - Rocket Ripple
Ground Crew - Chaff Program
Ground Crew - Flare Program
Landing Gear Lever
Gear Alternate Release Reset Control
‘Armament and Jettison Switches
External Stores Jettison Handle
Battery Switch
Extemal Power
Left Console
Circuit Breakers
Rudder Trim Knob
Radar Made Selector
Flap Lever
Throttles
Speed Brake Switch
Flap Thumb Switch
Nose Strut Switch
Antenna Switch
Compass Switch
SST-181X Switch
Left Vertical
Fuel Shutoff Switches
‘Amament Light Control Knob
Landing & Taxi Light Switch
Landing Gear Alternate Release Handle
‘AIM-9 Missile Volume Control
‘Atmament and Jettison Switches
Extemal Stores Jettison Handle
Instrument Panel
Landing Gear Lever
Drag Chute Handle
Flight Instruments
Optical Sight Mode Selector
‘Aux Intake Doors Indicator
Pedestal
UHF Radio
TACAN
Control Transfer Panel:
NAV Switch
Radar Switch
Comm Switch
Rudder Pedals
Brakes
Circuit Breakers
Right Vertical
Cockpit Pressure and Temp. Controls
Antiee Switches
Extemal Fuel Transfer Switches
Fuel Boost Pump Switches
Crossfeed Switch
Auto Balance Switch
Canopy Jettison T-Handle
Check and set
Check and set
Check and set
LG DOWN,
RESET
OFF and SAFE
N
‘As Required
‘As Required
Check and set
Centered
OFF
THUMB SW
OFF
Neutral
up
RETRACT
‘As Required
‘As Required
‘As Required
LEFT and RIGHT (guarded)
‘As Required
OFF
Fully Stowed
Fully Counterclockwise
OFF and SAFE
IN
LG DOWN,
In
Check and Set
‘As Required
Barber Pole
‘As Required
‘As Required
‘As Required
‘As Required
‘As Required
Adjust
Check
Check
‘As Required
OFF
OFF
LEFT and RIGHT
OFF
Centered
In
Battery Switch
Aux Intake Doors Indicator
Generator Switches.
Antenna Switch
Compass Switch
SST-181X Switch
Right Console
Oxygen System
Supply Pressure Gage
Quantity indicator
Supply Lever
Diluter Lever
Emergency Lever
IFF/SIF
Fuel and Oxygen Check Switch
Interior Lights
Exterior Lights
Rotating Beacon
Light Warning Test Switch
BEFORE STARTING ENGINES
External Power
Seat
Danger Areas Fore and Aft
STARTING ENGINES
LEFT ENGINE
External Air
At 10% RPM, Start Button
Throttle
Engine Instruments
Engine RPM
ecT
Nozzle Position
Oil Pressure
Hyérauli Pressure
Generator Caution Light
Aux Intake Doors Indicator
RIGHT ENGINE
Same as for Left Engine
‘Aux Intake Doors Indicator
External Power and Air
CROSSBLEED START
External Power and Air
LL Engine RPM
R Engine Start Button
At 10% RPM, R Throttle
Engine Instruments
U Throttle
Generator Caution Lights
‘Aux Intake Doors Indicator
Hydraulio Pressure
Batt
CLOSE
LGEN and R GEN
AAs Required
As Required
‘As Required
Check
Check (65- 110 psi)
Check
oN
NORMAL,
NORMAL,
sTBY
GAGE TEST and QTY CHECK
As Required
As Required
AAs Required
Test
Connect (if necessary)
‘Adjust (if AC power on)
Clear
Apply
PUSH
Advance to IDLE
Check within limits
49% 52%
Indication
60%- 79%
5-20psi
200-2200 psi
out
Barber Pole
OPEN
Disconnect
Disconnect
95%
PUSH
IDLE
Check within limits
IDLE after R Engine is at
Idle RPM
out
OPEN
2800-8200 psi
TOFS
REVISIONS AUG T2016F-SE TIGER Il QUICK REFERENCE CHECKLIST - NORMAL PROCEDURES.
FOR COMPLETE INFORMATION REFER TOT.0. 1F5E1
BEFORE TAX! cume
Gircuit Breakers Check External Fuel/Autobalance
Radar Mode Selector As Required Oxygen
Speed Brake in GockpitPressurization
Flap Thumb Switch auto AAU34/A Altimeter
Damper Switches ‘YAW and PITCH
Pitch Damper Cutoff Switch Check FUEL BALANCING
Pitch Damper Cutoff Switch Actuate AUTOBALANCING
Pitch Damper Switch Moves to OFF Auto Balance Switch
Pitch Damper Switch pire
Flight Controls ‘Check MANUAL BALANCING
Pitch Tim Check and Set Crossfeed Switch
Aeron Trim Fuel Boost Pump Switch
AAU36/A altimeter eect Fuel Boost Pump Switch
Field Barometric Pressure set
Function Switch PNEU cRUISE
PNEU flag Visible AAUSA/A Altimeter
Indicated Atitude 475 ftof fed elevation
Function Switch ELECT DesceNT
PNEU flag Not visible Armament Safety Check
Indicated Altitude 460 fof fed elevation Canopy Defog, Engine Anttice and
Field Elevation Difference 75 UPNEU vs ELECT Pitot Heat Switches
Standby Atitude indicstor Check, Set and Uncage Onygen
Wheel Brakes Apply Heavy Pressure: AAU-34/A Altimeter
Nosewheel Steering Engage (apply L and R rudder)
and hold each for 5 seconds), BEFORE LANDING
Wheel Chocks Removed AAU-34/A Altimeter
Crossfeed
Taxi Hydraulic Systems
Whee! Brakes Release Flap Thumb Switch
Nosewheel Steering Engage Landing Gear Lever
Flight Instruments ‘Check ‘Aux Intake Doors Indicator
Navigation Equipment Check AOA
BEFORE TAKEOFF LANDING
Nose Strut exTEND Patter alttude
Rader As Required Downwind Leg/Approach
Antiice Switches ‘As Required Final Approach
IFF/SIF ‘As Required Flare and Touchdown
Flight Controls Check
canopy Closed
Caution and Warning Lights out
After Touchdown
TAKEOFF
Whee! Brakes Apaly rag Chute Handle
Throttes ML
Engine Instruments Check G0 AROUND
Wheel Brakes Release Throttles
‘Nosewheel Steering AsRequired< G0 KS | speed Broke
Throttes ‘As Required Landing Gear Lever
At Stick {At 10kts below Flaps
takeoff speed
AFTER TAKEOFF AFTER LANDING
Landing Gear Lever Loup Orag Chute
Flap Thumb Switch As Required Cabin Pressurization Switch
‘Aux Intake Doors Indicator Check CLOSE (approx 255 | Flap Thumb Switch
£10 KIAS of 0.4 Mach) Speed Brake
Rader Mode Selector
Pitot Heat and Engine Antbice Switches
AAs Required
NORMAL,
Check
As Required
LEFT LOW or RIGHT LOW
LEFT LOW or RIGHT LOW
OFF (low fuel side)
LEFT of RIGHT (low fuel side)
Check
Complete
AAs Required
Check
Check and Set
Check and Set
Discontinue
Check Pressure
AUTO
Ls DOWN
OPEN
On Speed
300 KIAS, 1500 ft
260 KIAS, 1500 ft
165 KIAS, 1000 ft/min desce
145 KIAS.
AOA Indicator at 3 o'clock
AOA Indexer On Speed
12 degrees pitch maximum
Lower nosewheel to
‘ground (approx 3 seconds)
out
MIL/MAX (ifnecessary)
IN
Lg uP
As Required
Jettison
RAM DUMP
up
out
OFF
OFF
TOFS
REVISIONS AUG T2016F-SE TIGER Il QUICK REFERENCE CHECKLIST - NORMAL PROCEDURES.
FOR COMPLETE INFORMATION REFER TOT.0. 1F5E1
IFF/SIF
Rotating Beacon
ENGINE SHUTOOWN,
canopy
Wheel Brakes
Chaff/Flare Switches
Pitch and Yaw Dampers
Radar Mode Selector
Speed Brake
Landing Gear Alternate Release Handle
‘Armament and Jettison Switches
Standby Attitude Indicator
Optical Sight Mode Selector
Radar Warning Receiver
UHF Radio
TACAN
Cabin Pressurization Switch
Temperature Controls
Pitot Heat and Engine Ant-Ice Switches
Extemal Fuel Transfer Switches
Crossfeed Switch
‘Auto Balance Switch
(Oxygen Supply Lever
Diluter Lever
Emergency Lever
Throttles
Generator Switches
Fuel Boost Pump Switches
Exterior Lights
Rotating Beacon
Interior Lights
Battery Switch
OFF
‘As Required
Open
Hold until chocks in place
OFF
OFF
OFF
out
Stowed
OFF and SAFE
Caged and locked
OFF
OFF
OFF
OFF
NORMAL
‘As Required
OFF
OFF
OFF
Centered
OFF
NORMAL
NORMAL
OFF
OFF
OFF
OFF
OFF
OFF
OFF
TOFS
REVISIONS AUG T2016[TAKEOFF
[CENTER OF GRAVITY [LIFTOFF SPEED,
WEIGHT, ‘STORES, AMMO POSITION, s Mac ee
"15000 AND LESS_|NONE 7-18 fag 145,
"18500-17000 [GUN AMMO, MISSILES: ig-14 54-156,
[17000-78000 [FUEL POD, GUN AMMO, MISSILES 15-16 Hiss 160,
"18000-19000 |FUEL POD, GUN AMMO, MISSILES. 5-16 h60- 165,
"19000 20000 |FUEL POD, GUN AMMO, MISSILES 15-16 hes 170,
[20000-71000 | FUEL POD, GUN AMMO, MISSILES 15-16 70-175
"13000-20000 | BOMBS, ROOKETS, CENTER FUEL PODS, GUN AMMO, MISSILES [10-12 ii75-180,
[20000-21000 BOMBS, ROCKETS, CENTER FUEL PODS, GUN AMMO, MISSILES _|10=12 feo 185,
[21000 AND MORE BOMBS, ROCKETS, CENTER FUEL PODS, GUN AMMO, MISSILES [10-12 fies 199,
‘APPROXIMATE TAKEOFF | AIRCRAFT CENTER OF GRAVITY POSITION,
CONFIGURATION. MAC INDICATED PITCH TRIM POSITION
WITHOUT GUN AMMO, WITHOUT
ae 18 AND MORE 6
FUEL POD, AMMO, MISSILES 1aTo18 7
FUEL POD, AMMO, MISSILES, BOMBS,
mo, MISS 107013 8
GUN AMMO, MISSILES, BOMBS,
ROCKETS, CONTAINERS OAND LESS °
Vavu'oscli- 145+S(if there is gun ammo)+(fuel remaining -1000)/200
IAS, Le. Speed before turning (0
160 KS.
LANL es ae il cam cn eel 3 pea ree the SO