ae TELANGANA STATE POLLUTION CONTROL BOARD
REGIONAL OFFICE, WARANGAL
SaSaZ H.No, 1-8-269, Balasamudram, Hanamkonda, Warangal District - 506001
I
R. SUNITHA, M.Tech. Phone No. 0870-2577269
ENVIRONMENTAL ENGINEER e-mail: ce-wglu-tspcb@telangana.gov.in
Order No. 2500/WGL/070/PCB/RO-WGL/2022— 5G Q Dt: 31.10.2022.
ACKNOWLEDGEMENT
(For SSI Units other than 66 Categories only)
(See Rule No. 32-A of the Water (Prevention and Control Pollution) Rules 1994 and
Rule No. 29-A of the Air (Prevention and Control Pollution) Rules 1994.)
The Consent application submitted by M/s. Mallikarjan Rice Mill to establish and to
operate their unit at Sy.No. 222/e95°, Chandrugonda (V), Nekkonda
District to carryout Raw Rice Mill (Rice Hullers Only) — 32 TPD is hereby
acknowledged as the unit is not covered under Schedule No. IV & II of above said Rules.
This acknowledgement is treated as consent of Telangana State Pollution Control Board,
subject to the following conditions.
1. In case, of any expansion or change in manufacturing process, raw materials or
products, a fresh application shall be submitted.
2. All the rules notified by the State and Central Governments under Environmental
laws from time to time, which are applicable to this unit shall be complied with.
3. The industry shall comply with general standards notified by the Ministry of
Environment and Forest. Government of India vide extra ordinary Gazetted
notified No. 174, Dated 19 May 1993 as amended from time to time.
4. The unit should not be established in residential area or close to sensitive areas
such as Hospitals, Monuments, Schools, Zoological Parks, etc.,
5. The unit shall construct rain water harvesting system for enhancement of ground
water.
6. The officials of Telangana State Pollution Control Board may inspect the unit at
any time to verify the compliance status and may also stipulate such conditions as,
are deemed to be fit.
7. The unit shall not start operation of raw rice milling activity until the construction
of closed husk room to control fugitive emission to the surrounding area,
8. The industry shall develop 33% of the total area as thick green belt all along the
boundary of the unit.
9. The unit shall store husk in closed room. Husk shall not be stored openly under
circumstances.
10. The Board reserves its right to modify above conditions or stipulate any further
conditions and to take action including revoke of this order in the interest of
environment protection 5
Date: 31.10.2022. 3)o}az
ENVIRONMENTAL ENGINEER
SeSM4RONMENTAL ENGINEEH
To “olangana State POLLUTION CONT! 1
Sri Sangani. Suraiah, S/o. Muthaiah, BOARD REGIONAL OFLICs
H.No. 3-58, Chandrugonda (V), Nekkonda (M), WARANGAL
Warangal Distriet - 506122
Copy Submitted to:
1 The Member Secretary, TSPCB for kind information.
2 The JCEE, Zonal Office, Hyderabad for kind information.
3. The GM, DIC, Warangal District for kind information.