Professional Documents
Culture Documents
Eee-235 - A-1
Eee-235 - A-1
Contents
1. Objectives
2. Theory
3. Operating Principle for Amplifier
4. Dc Biasing
5. Circuit Diagram
6. Small Signal Analysis
7. Discussion
1.OBJECTIVES
For each of Common Source (CS), Common Gate (CG), Common Drain
(CD) amplifiers
2. To perform dc biasing
2.ThEOry
For using MOSFET as an amplifier circuit, first of all ensure that the
MOSFET operating in saturation region. Because only saturation
region’s linear part can only amplify input signal as a distorting output
signal. The region of MOSFET cut off and triode are basically used for
switch. In Voltage Transfer Characteristic Curve (VTC) in fig.1 we can
see that the input signal is totally amplify when it operates in saturation
region linear part. But when input signal is much more then it goes to the
non-linear part of the saturation region. That’s why we get distorting
output signal.
For Amplifier circuit, we give VGS (Gate to Source Voltage) as an input
signal and take output from Drain to source Terminal V DS in Fig.1.
3. OpEraTIng prInCIplE
At first, we have to operate MOSFET at saturation region for amplify
the input signal. After that fixed the operating point at saturation region.
Without distorting to get output signal dc biasing is most important fact.
The device is basically biased at a point which is located middle of the
saturation region in liner part. This point is called operating point or Q
(Quiescent) point of MOSFET for an amplifier Circuit. To keep stable
Quiescent point for accurately amplify input signal, we have to stable
the Predictable/Desire dc Drain current ID.
4. pErfOrmanCE Of dC BIaSIng
(a) Biasing by fixing VG and Source resistance (RS) for Common-
Source (CS) Amplifier:
In this biasing, we have to apply fixed VG voltage at the gate terminal.
There is also a Source Resistance RS at a source terminal (Fig 4.1)
Let, the ID current flows through the drain to source terminal. Therefore,
VG = VGS + IDRS.
Let, the ID current is increase due to the outside effect, the IDRS voltage
drop is also increase.
ID1 = VDD+VSS-VGS/RSET.
Input voltage
Therefore,
Input Voltage
𝟏
𝒈𝒎
Vin = 𝟏
𝒈𝒎 𝑹𝒔𝒊𝒈
id = −gm ∗ Vin
Rout=RD
Output Voltage,
Rin = RG
Output Resistance:
Input voltage
Here, RG>>Rsig
Vin= Vsig
Output voltage
Voltage gain
7. dISCuSSIOn
Normally there are four types of biasing of MOSFET
amplifier but among them the constant current source
biasing is most widely used and best of them.
In Common – Source ( CS ), Common – Gate ( CG)
and Common – Drain (CD) amplifier circuit
configuration, the common face configuration is most
widely used and popular.
Without distorting to get output signal we have to
keep in mind that the input signal must in a certain range.
Otherwise we don’t get our expectable output signal.