MINIMUM REQUIREMENTS FOR SUBMISSION OF SAMPLES
MATERIALS
. Cement
. Asphaltic Materials
Asphalt Mix
Aggregates
a. Coarse Aggregate
b. Fine Aggregate
Soil Aggregate
a. Classification
{ b. Routinary Tests
“\ ¢. Moisture Density
Relation & CBR
Non-reinforced Concrete Pipe
ae
x
. Reinforced Concrete Pipes
. Steel Pipe (Galvanized)
2
. Concrete Hollow Blocks
(Complete)
a. Strength
b. Moisture Content
10. Stee! Bar
11, Steel Sheet (Galvanized)
12. Wire - Strand
Strap
13. Gabion
14. Paints
45. Joint Filler (Pre-mold)
16. Curing Compound
17. Concrete Cylinder
18. Concrete Beam
19. Concrete Core
20. Asphalt Cores
21, Water Analysis
a. Chemical Analysis
b. Sediment Load
22, Structural Steel/Sheet
23. Thermoplastic Paint
24, Reflective Pavement Studs
MINIMUM TESTING
REQUIREMENTS
1 Sample per 2000 Bags
4((s) per 40 Tonnes
of 200 drums
1(s) per 130 Tonnes
4(s) per 1500 cum
1 (s) per 1500 cum
2 Pipes min./0.5% of
No. of Pipes
1 (s)/50 pipes or 2% of
No. of Pipes
1(s) per 500 length
4 (s) per 10,000 units
1 (s) per 100 cans
1 set of 3 cylinders for
@75.cum
1 set of 3 beams for 75 cu.m,
_ day pouring
6 cores for every kilometer
1 core for every 100 meters
1(s) per 50 tonnes
10 kis for every 100 bags
Plus 500 gm. Glass beads
3 samples per 10.000 ocs.
MINIMUM QUANTITY/VOL. O!
MATERIALS FOR EACH
SAMPLE SUBMITTED
10 kg
SL
20 kg. (Complete)
70kg
50kg
20kg
50 kg
50 kg
2 pipes
1 pipe ( 1 m length)
2 pcs. Of 100 mm long taken from
both ends wio thread
6 units
3 units
3 units
1 meter
1 sheet
2 meters
imx2m
1(4L cans)
4 (20L cans)
1 (400mm x 400mm)
1 liter
1 set of 3 cylinders (6” x 12")
1 set of 3 beams (6” x 6" x 21")
500 ml
500 ml
Reduced section (as prescribed)