Professional Documents
Culture Documents
There is also an example radvd.conf file in the aditl lab (under router1/etc
directory). When doing the assignment you should configure radvd.conf file
correctly, start radvd and take care that your radvd.conf file has no “write”
permissions, otherwise radvd will not start.
Tip: Watch out that all your IPv6 interfaces are in “UP” state before you can send
and receive routing advertisements.
We will reuse the lab from the previous assignment. For the IPv6 network
addresses the network drawing and IP address range per group table below will
be used.
Netkit Collision Domain A
Local Network 2001:21:1:210x::0/64 Netkit Collision Domain B
ISP Network
2001:23:1:21Ex::0/64
Laptop
DnsServer
Router1
A
Router2
Prove your correct routing configuration by using ping command. The ping has
to work between any 2 nodes of your configuration.
Explain how your automatic IPv6 addresses were formed based on one example
autoconfigured IPv6 address.