Professional Documents
Culture Documents
Lea primero!
General Technical Specifications
Lea detenidamente este manual antes de utilizar la
Connection/Mounting Type Series, DIN-Rail mount unidad. Conserve este manual coma referencia para
futuras consultas. El dispositivo sólo puede ser instalado
SPD Type 2 CA y puesto en funcionamiento por personal cualificado.
Using The Active Tracking Filter® To Control Low- And High-Voltage Transients
Low-Voltage Transients High-Voltage Transients
Before After Before After
The Active Tracking
Lower-voltage The Active
Filter® eliminates
transients (high- High-voltage spikes Tracking Filter®
potentially damaging
frequency noise) appearing on 120V, virtually eliminates
noise, providing
appearing on 120V, 60 Hz sine wave. high-voltage
clean and reliable AC
60 Hz sine wave. transients.
power.
2
Typical Wiring Diagram
Grounding:
Unprotected Side
Input and output ground
terminals must be
Ground connected for proper
Neutral/Line 2 operation. Incorrect
grounding can reduce or
AC
Power impede the performance of
Input this unit. A green (with or
Removal
Fuse or CB without one or more yellow
strips) insulated ground
Line conductor, identical in size,
See Table 1 insulation material, and
for fuse/CB thickness to the grounded
rating and ungrounded conductors
must be installed (ref.
NEC,Table 250-95) and 2
referenced back to an
acceptable building earth
3
ground.
Summary Alarm
Contacts
NO Ground
Tel. (81) 8333 8788
Common Neutral/Line 2 LOAD DISTRIBUIDOR AUTORIZADO 01 800 273 2684
NC Line
www.secovi.com email: informes@secovi.com
Protected Side