• Disconnect the electrical wires entering the electric motor cover
• Disconnect the circuit pump • Remove the screws (1) • Uncouple the pump unit (2) and o-ring (13) • Unscrew the caps (3), making sure you secure the impeller using a soft belt, so as not to damage the paddles • Extract the impeller (4) from the shaft (10), taking care with the seal o-ring (11 and 12) • In the case of MB 80/130 – TS pumps, extract the mechanical bellows seal (5) together with the metallic cylinder (8) and the silicon ring including its o-ring (14 and 15) • In the case of MB 130/180 – TS pumps, extract the mechanical bellows seal (5) and the silicon ring including its o-ring (14 and 15) • In the case of MB 80/100 – TS pumps, uncouple the seal support flange (6) from the remaining elements • In the case of MB 110/180 – TS pumps, uncouple the seal support flange (17) from the rear flange (19), removing the securing screws (16); the seal o-ring should also be removed together with this (18) • Remove the screw (9) securing the lantern to the electric motor • Extract the lantern (7) • Slacken the dowel (not visible in the image) used to secure the pump shaft to the electric motor shaft and proceed with the extraction.
Dismantling a Centrifugal Pump
• Disconnect the electrical wires entering the electric motor cover
• Disconnect the circuit pump • Remove the screws (1) • Uncouple the pump unit (3) and o-ring (7) • Unscrew the caps (2), making sure you secure the impeller using a soft belt, so as not to damage the paddles • Extract the impeller (5) from the shaft (14), taking care with the seal o-ring (4 and 6) • Extract the ceramic cylinder (10) together with the spacer washer (11) • In the case of MB 80/100 – TL pumps, uncouple the seal support flange (8) from the remaining elements • (B) In the case of MB 110/180 – TL pumps, uncouple the seal support flange (16) from the rear flange (18), removing the securing screws (15); the seal o-ring should also be removed together with this (17) • NB: only extract the lip seal (9) from its seat if it is damaged • Remove the screw (12) securing the lantern to the electric motor • Extract the lantern (13) • Slacken the dowel (not visible in the image) used to secure the pump shaft to the electric motor shaft and proceed with the extraction.