Professional Documents
Culture Documents
com
- The receiver it's not as sensitive as as a JFET one is, but it's a great
project to build with good performance.
- The audio level depends a lot on the speaker you use. Don't use small
speakers, as they have low performance.
- For good results use a good antenna, like a hald wave end fed wire for the
40m band.
The file to print is already prepared ( for toner transer method ) so there is
no need to chnage or edit the image.
Just print it as it is, making sure you set the printer to print with ought any
margins.
Check the dimensions of the printed image before transfering it to the PCB
( 100mm x 75mm ).
For:
ciprianipopica@gmail.com
The Schematic and PCB design were designed in Express PCB and Express SCH.
You also have here the schematic and PCB design files in case you want to make
any changes.
I also included PDF files with the prints. Use whatever works for you.
PARTS LIST:
Integrated Circuit:
LM386 x 1
Voltage Regulator:
L7809CV ( Can be replaced by a 470 Ohm resistor / 0.5 W or 1 W )
Transistors:
2N2222 x 1
2N3904 x 2
Diodes:
1N4001 x 1
1N4004 x 2
LED 3mm Red x 1
Resistors:
10 Ohm x 1
1 K Ohm x 1
2.2 K Ohm x 2
4.6 K Ohm x 1
10 K Ohm x 3
20 K Ohm x 1
100 K Ohm x 1
Electrolytic Capacitors:
0.47 uF x 2
10 uF x 3
470 uF x 3
Trimmer Capacitors:
10:40 pF x 2
Potentiometers:
1 K Ohm x 1
10 K Ohm x 2
10 K Ohm x 1 ( Multiturn potentiometer )
Inductors:
L1 - 3 Turns and L2 - 32 Turns both on a T50-2. ( L1 on top of L2 as seen in
the drawing )
L3 - 100 mH ( Not critical, can be replaced by a jumper cable )
Switches:
Power x 1
CW / SSB x 1
Audio Filter x 1