Professional Documents
Culture Documents
Service Notebook IP Config
Service Notebook IP Config
Description
This document describes the procedure required to set a static IP address on a Service
Engineer computer to enable a connection to the QIAcube Connect via the QIAcube
Connect Service Software. This procedure is also described in the Service Manual.
1. To set a static IP address, open “Control Panel”, click “Network and Sharing Center”
page 1 of 3
QIAcube Connect Computer Configuration
3. Right click “Local Area Connection” to open the pop-up menu. Click “Properties” to
open “Local Area Connection properties”
page 2 of 3
QIAcube Connect Computer Configuration
8. After you are done servicing the QIAcube Connect, reset the setting to “Obtain an IP
address automatically” or you will not be able to connect to standard networks.
page 3 of 3