Professional Documents
Culture Documents
Technical Bulletin
39-30005-001
REV: A
Published by PCSC
3830 Del Amo Blvd., Suite 102
Torrance, CA 90503
Phone: (310) 638-0400
FAX: (310) 638-6204
Information in this manual is subject to change without notice and does not represent a
commitment on the part of PCSC. The software described in this manual is furnished under a
license agreement or nondisclosure agreement. The software may be used or copied only in
accordance with the terms of the agreement. No part of this document may be reproduced or
transmitted in any form or by any means, electronic or mechanical, including photocopying,
recording, or information storage and retrieval systems, for any purpose other than specified in
the agreement, without the express written permission of PCSC.
Published by PCSC
3830 Del Amo Blvd., Suite 102
Torrance, CA 90503
Phone: (310) 638-0400
FAX: (310) 638-6204
Required Equipment:
1. PC or Notebook computer with a NIC
2. Web Browser (IE 5 or greater or Netscape 5 or greater.)
3. Ethernet Cross Over cable (example: Unicom E5DD-C414-WT-10TR) or attached to
a hub
4. IQ 200/201 – 03-10100-xxx
5. SIM – 03-10104-xxx
6. IQ LAN – 03-10108-xxx
Required Information:
1. LiNC-NET Host IP Address
2. IQ LAN IP Address – This is the unique IP Address for each IQ or SIM.
3. Panel Number – This is the IQ or SIM panel number that the IQ LAN will be attached
to. The panel number in the IQ LAN and the IQ or SIM PCB must match.
4. Any Gateway information.
Required firmware:
1. IQ-200 panel firmware: IQ-7.9.17gi or greater (or)
SIM Panel firmware: SI 7.9.17gi or greater
2. IQ LAN version 0124 or greater
The following steps are for connecting and changing the TCP/IP Configuration.
1. Connect your Cross Over cable from your host to the IQ LAN
Note: Once you have powered up the IQ or SIM and have successfully made a
connection to the Host, the IQ LAN R45 connectors Green LED will turn
ON. You will also see the Yellow LED strobe when it is trying to
communicate to the Host.
2. Open your Browser (e.g. Internet Explorer, Netscape, etc.)
3. Request the configuration form by entering the following in the “Address” field of the
Browser. http://192.168.168.32
4. An html form will appear (figure on next page).
If the the IQ/SIM LAN board is accidentally set to an incorrect (and/or unknown) IP address, it is
possible to reset the IQ/SIM LAN board to original default IP address.