Professional Documents
Culture Documents
br
DRUM SET
SETUP
1
STEP 2
A
practical
guideline
for
BY
setting up
a
3 drum set
STEP
www.cliqueapostilas.com.br
1 drum shell,
12 wing screws with washers,
12 claw hooks,
BASS DRUM 1 bottom head,
1 batter head,
2 rims,
2 bass-drum legs (spurs)
2 x 10 wing screws
with washers
1 dum shell,
10 wing screws with washers,
2 heads,
FLOOR TOM 2 rims,
3 legs
1 tuning key,
ACCESSORIES 1 pair of drumsticks
Ride cymbal,
CYMBALS Crash cymbal,
(if included in scope of delivery) 2 hi-hat cymbals
www.cliqueapostilas.com.br
HARDWARE PACKAGE
1 bass-drum pedal
1 hi-hat stand
1 snare-drum stand
2
www.cliqueapostilas.com.br
3 4
NOTICE:
Fasten the screws in a criss-cross fashion (op-
posite screws) and screw only to the point
where you feel a slight resistance (Fig 7).
7
www.cliqueapostilas.com.br
5
www.cliqueapostilas.com.br
4
www.cliqueapostilas.com.br
HI-HAT
HI-HAT
3 4 5
6 7
www.cliqueapostilas.com.br
1 2 3
4 5 6
7 8 9
Fig. 1: Now guide the lower hi-hat cymbal (which is marked Fig 6: Tighten the locking nut so that the cymbal is fixed.
with “bottom”) through the tension rod and place it onto
the hi-hat support felt-pad as illustrated. Fig. 7: Finally guide the upper hi-hat cymbal with the assem-
bled holding system through the tension rod and tighten it.
Fig. 2: In this figure, you can see the holding system of the
upper hi-hat cymbal. The first felt pad is already mounted. Fig 8/9: Press the tension rod a little bit downwards and
tighten the locking screw at the point where upper and
Fig. 3: Place the upper hi-hat cymbal onto the felt pad of lower cymbals are about 1 – 2 cm ( 0.4 – 0.8 inch) apart.
the holding system.
Fig. 4/5: Now place the second felt ring and then the metal
disc onto it.
www.cliqueapostilas.com.br
1 2 3
7 8 9
www.cliqueapostilas.com.br
ASSEMBLING
THE SNARE-DRUM STAND
Using the wing nut at the joint you can set the
snare-drum inclination angle as needed.
2
www.cliqueapostilas.com.br
4
www.cliqueapostilas.com.br
MOUNTING OF TOM-TOM I
TOM 1
AND 2 TOM 2
1
Fig.1/2: Fasten the two tom-tom mounting
arms to the mounting assembly on top of the
bass drum and adjust the appropriate angle for
taking-up the tom-toms.
5
www.cliqueapostilas.com.br
TOM 1
Fig. 6/7: The tom-tom holders are equipped with
memory locks allowing a quicker setup next
time.
TOM 2
Slide the locks onto the mounting assembly or
tom-tom holders and tighten them with the key.
FLOOR TOM
FLOOR TOM
2
www.cliqueapostilas.com.br
6 FINE TUNING
CLOSING
REMARKS
LET IT ROCK!
NOTES
www.cliqueapostilas.com.br
Musikhaus Thomann
Treppendorf 30
96138 Burgebrach
Germany
tel.: +49(0)9546-9223-40
fax: +49(0)9546-9223-6774
email: drums@thomann.de
internet: www.thomann.de