You are on page 1of 4

1.Find current in all resistances in the circuit shown in figure.

2. State and explain KCL and KVL with sign convention

3.Define the following terms a) Active Power b) Power factor c) RMS value d) Average
value of an AC quantity

4.Write a note on BH curve and its importance.

5.Explain Leakage Flux, Bad effects of leakage flux and Fringing

with neat diagram.

6. Define Average value of ac variable. Expression for average

value of sinusoidal variable

7.Find the current in 5 ohm resistance in given circuit

8. State the importance of high pf. State reasons for low pf.

9. State advantages of low pf and method of improvement of pf by using parallel


capacitor branch.
10.Explain Series AC circuit with resistance and inductance.

11.Define the following terms and state the units: a)Magnetic flux density b)Magnetic
field strength c)Reluctance
12.Define and derive the expression of RMS value of sine wave AC.

13.A resistance of 20 ohm is connected in series with capacitance of 500 Micro Farad. AC
voltage of 200 V, 50 Hz is applied to the branch. Find Active power, Reactive power and
Powerfactor.
14.Explain resistive AC circuit & Derive expression for average power drawn.
15.A non inductive resistor of 5 ohm is connected in series with pure inductance of 5mH.
Find power drawn, pf, reactive power, impedance and current if applied voltage is 200V
(rms), 50Hz.

16.Find resistance RAB for the circuit shown in following Fig.

17.Find voltage across 300 ohms and 200 ohms in circuit shown in following figure.

18.A steel ring of mean diameter 10 cm has a saw cut of 2 mm in it. The ring is wound with
300turns of a coil carrying 4A current. Relative permeability of steel is 800.Find flux
density in the air gap.

19.A soft iron ring of mean diameter 15cm is uniformly wound with 170 turns of an insulated
copper wire. 1.8 A dc current is passed in the coil. Find flux density in the ring if relative
permeability of soft iron at that flux density is 600.

20.Explain similarities & dissimilarities between electric & magnetic circuit.


21. With neat diagram, explain construction of DC Motor.
22. Draw the speed torque characteristics for (i) dc series motor (ii) dc shunt motor. State two
applications of each of the above motors
23. Explain with neat diagram basic principle of electric Motor.
24. Draw circuit diagram for 4 types of dc motor.
25. Derive EMF equation of transformer
26. Define transformer? State its operating principle.
27. Explain construction of core type & shell type transformer.
28. Describe working of a transformer (i) no load (ii)With load.
29. For a transformer, define and Explain (i) Efficiency (ii) Voltage regulation
30. Certain transformer while working on 230V at no load draws 100 W power at 0.3 pf
lagging. Find the current drawn. Also find magnetizing component and core loss component
of the current.
31. A 230V/115V, single phase transformer operates on full load, when the load voltage is
112V. Find the voltage regulation.
32. A 230V/115V, 2 KVA, 50 Hz single phase transformer supplies full load of upf. The full
load Copper loss is 100W. Find equivalent resistance as referred to secondary. Hence find
the voltage regulation.

You might also like