Professional Documents
Culture Documents
2. Make sure that your computer gets its IP address (192.168.0.xx)/24 and its default
Gateway is (192.168.0.1)/24.
Note: You can configure static IP address in your PC to access the router (for example:192.168.0.3/24).
Page | 1
3. Go to your browser and enter the IP (192.168.0.1). When it prompts for Authentication,
enter user name (root) and password (root) then Log In:
Then, you will see the main web page in your screen:
Page | 2
4. From the navigator menu in the left, choose , then determine the Operation
Mode as shown in the figure:
5. The next page shows the router current IP (you can change it):
Page | 3
6. After you finish the LAN settings, you will have to set WAN1 settings as shown in the
figure:
Set VPI to 1 and VCI to 35(you can check this parameters with Yemen Net).
Choose EoA Protocol.
When you’re done click button.
7. On this page you will have to complete WAN1 settings as shown in the figure below:
Enter the WAN IP address with its Subnet Mask and Gateway.
Note:
-IP addresses used in the figure are just examples so you should use your own IP addresses.
- Gateway IP address will be the default route. If this router used in the HQ, leave the gateway blank then add
your routs in the static route page.
Page | 5
9. To add special route (referring to your network IP address Map) go back to your browser
again and follow this chart:
In the Table of Current Static Route Entries you can add your network paths referring to
your network topology and IP map. When you’re done click button.
For more information you can read the manual in the CD.
Page | 6