Professional Documents
Culture Documents
2018 年 10 月 28 日
1.Product Appearance
disconnected;
connecting finger : Plug into the smart card slot of the UPS; include power
supply interface: DC 9-24V power input; rated voltage DC12V, rated power
consumption 3W;
Product size
2.Product installation
(Note: The intelligent network monitoring terminal is referred to as "snmp card" in the following description)
[installation]: Insert the snmp card into the designated slot of the machine;
It should be noted that the default IP address of the snmp card is 192.168.0.100.
In any case, you need to ensure that the IP is not used in the current network
environment. Otherwise, you will not be able to enter the background web page
configuration.
Figure 1
3) After having searched the device successfully, it will list it's IP address, MAC address, subnet
mask, gateway, hardware version, firmware version, et. Select the device you want to set, double-
click it, and interface shown in Figure 2
Figure 2
4) In the "OPTION" dialog box, double-click the column of IP address. Then enter the new IP
address (default address is:192.168.0.100) in the newly pop-up dialog box and confirm it.
5) Subnet mask and gateway can be modified in the same way as step 4. (Other columns of this
page are not suggested to modify)
6) After completing all the modifications, return to the OPTION dialog box which shows all the
modified data, but not effective yet; click "automatic reboot ", enter administration password
(default: admin) and confirm it.
7) After automatic rebooting, the new IP address becomes effective. (If necessary, check it by
researching the IP address.)
3.1 Log in to the snmp card background page
In the web browser, enter the IP address of the snmp card: 192.168.0.100, press Enter, and enter
the user name admin password admin in the pop-up window to enter the monitoring page of the
snmpcard.
Basic settings
SNMPsettings
Permission settings
Authorized IP address : Set the computer IP address you use to read the snmp
card. As shown in the figure,the IP address of the computer used to read the snmp
card is 172.16.0.221.
Community:Generally public
Authority:read、write or read-write。
TRAP settings
Receive enable:You need to check the box to use the trap function.
Community:Generally public
1. Get the QR code and you need to make sure that the monitoring card can access the Internet
normally;
2. Check Enable WeChat cloud monitoring to display and enable cloud monitoring;
3. Implement device attention binding and data viewing by scanning the QR code below using
WeChat.
Detailed WeChat interface operation instructions can be found using WeChat scanning QR code
below
Addendum :Simple test method for snmp card
Use the iReason MIB Browser to get the device's snmp data.。Enter the IP address of the device as
shown below: 192.168.0.100, click Advanced: Skip the small menu, enter port: 161,
ReadCommunity: public; WriteCommunity: public; SNMP Version: Select 2, click OK.
Load MIBS
After the loading is complete, use the walk command to get information about all nodes after the
selected cotyledon node, as shown below.