Professional Documents
Culture Documents
WONDERPEEL is formulated for protection of metals, plastics, glass, cement, and many kind
of surfaces. It is an ideal solution where coated substrates require temporary protection
against contamination or damage due to scratches or paint overspray during fabrication,
shipment and storage.
Water based
Solvent free
Non-flammable in liquid form
Easy and fast application
Easy to remove peelable film
Resistant to dirt, oil, acid rain, grease and paint overspray
Excellent elasticity and tensile strength
Compatible with most spray equipment
Can be applied with air gun, airless gun or brush
Not require chemical strippers or scraped off
INTENDED USES
WONDERPEEL is designed to provide excellent temporary protection in paint booth
walls of automotive , railway and aerospace industries .
Protect against a wide range of contaminants such as dust, oil, grease, acid rain, grinding
debris, fly rust and coating application overspray whilst providing a degree of resistance to
abrasion, and scuffing,
It’s ideal for use in automotive industry in car nurse transit , during assembly where
coated substrates require temporary protection against incidental contamination and
damage such as that experienced during transit.
WONDERPEEL
Peelable Temporary Protective Coating
PRODUCT INFORMATION
Colour : White
Volume Solids : 42%
Theoretical Coverage : 2.80 m²/litre at 150 microns (dry)
Method of Application : Airless Spray, Air Spray, Brush, Conventional Spray, Roller
Drying Times: Temperature Touch Dry Hard Dry
25°C (77°F) 30 minutes 1.5 hours
40°C (104°F) 20 minutes 1 hour
SURFACE PREPARATIONS
All surfaces to be coated should be clean, dry and free from contamination, dirt and oil.
Apply a wet continuous coat approximately 200-400 microns. A minimum of 150 microns dry
thickness is recommended. Coating should be tested to determine the best film thickness for
your application. In order to peel, it must be a continuous film. Overspray will not peel off. If
overspray exists, remove it as soon as possible using a wet towel or sponge.
APPLICATION OF PRODUCT
Recommended Conditions:
Temperature 15 - 30°C (59 - 86°F)
Relative Humidity 20 % - 80 %
SAFETY
All work involving the application and use of this product should be performed in compliance
with all relevant national Health, Safety & Environmental standards and regulations. Prior to
use, obtain, consult and follow the Material Safety Data Sheet for this product concerning
health and safety information. Read and follow all precautionary notices on the Material
Safety Data Sheet and container labels.
STORAGE RECOMMENDATIONS
Inspect the condition of the container to ensure compliance. The material should be stored at
temperatures between 13°C to 32°C (55°F to 90°F) to ensure shelf life. This is a water-base
compound and should be protected from freezing. Never allow this product to freeze. Once
frozen, application and protective properties are unstable and not warranted.
Maximum recomended storage time before use is 3 months after elaboration date.