Professional Documents
Culture Documents
Faa Approved Airplane Flight Manual Supplement P/N 140-590039-0095 For HF 2 Radio
Faa Approved Airplane Flight Manual Supplement P/N 140-590039-0095 For HF 2 Radio
Use the List Of Effective Pages to determine the current status of this supplement.
1 of 8 Original Issue 0
2 of 8 Original Issue 0
3 of 8 Original Issue 0
4 of 8 Original Issue 0
5 of 8 Original Issue 0
6 of 8 Original Issue 0
7 of 8 Original Issue 0
8 of 8 Original Issue 0
LOG OF REVISIONS
Rev Page Date
Description FAA Approved
No. No(s) of Revision
CONTENTS
Page
INTRODUCTION ................................................................................................... 7 of 8
HF Radios ...................................................................................................... 7 of 8
AVIONICS.......................................................................................................... 7 of 8
INTRODUCTION
This supplement applies to Hawker 750 airplanes equipped with HF2 Radio installation that have
Kit 149-3400 installed.
The limitations, procedures and information contained in other sections of this Airplane Flight
Manual are applicable except where superseded by the information given in this supplement.
SECTION 1 - GENERAL
ABBREVIATIONS and ACRONYMS
HF ............................ High Frequency
R/T ........................... Receiver Transmitter
CPLR .......................Coupler
SECTION 2 - LIMITATIONS
AVIONICS LIMITATIONS
HF Radios
1. When the ADF is being used for approaches, the use of the HF radio is prohibited.
If power failure to individual radio system components is observed or suspected, power may be
regained by operation of the PE, PS 1 and/or PS 2 AVIONICS MASTER BYPASS switches,
located at the lower right corner of the DA-A circuit breaker panel, behind the copilot.
The PS2 MASTER BYPASS switch controls the HF 2 radio. Circuit breakers for the HF 2 radio
system are located on the DA-A circuit breaker panel as follows:
SECTION 5 - PERFORMANCE
No change.