Professional Documents
Culture Documents
®
ARCAGEL 125 D Blue
Diazo photoemulsion for rotary printing screens
ARCAGEL 125 D Blue is used in textile and wallpaper printing for conventional film, CTS exposure, wax
and inkjet engraving of rotary printing screens. It has excellent flow properties, optimum resolution and
good reproduction of details. After heat curing, it shows excellent resistance to all commonly used
printing pastes. ARCAGEL 125 D Blue can be used as lacquer for laser engraving – in this case it is
being used without Diazo.
DEGREASING Before coating the nickel rotary screen with ARCAGEL 125 D Blue, we
recommend to degrease it with ARCACLEAN NOVO, so that the
photoemulsion has good adhesion to the nickel screen.
Single squeegee (immersion coating from top to bottom), coating speed 12-
15 cm/min:
The exact quantity of water must be adjusted to the coating method and type
of screen. Allow the photoemulsion to ventilate, if possible overnight.
DRYING After coating, drying is effected in a dust-free drying cabinet with fresh air
circulation for approx. 45 minutes at approx. 30°C. Drying at room
temperature is not recommended.
Before exposure, do not expose the coated and dried screen to daylight or
any other UV-light sources.
EXPOSURE The printing stencil is produced by hardening the non-printing screen area
with UV-light. Blue-actinic light in the wave-length range between 350-400 nm
is required; especially suitable light sources are metal-halide lamps. Owing to
the high number of parameters that can have an influence on exposure time,
no absolute values can be given. Optimum copying results can only be
achieved by trials (step exposure).
This data sheet is for your information, a legally binding guarantee of the product's suitability for a particular application cannot be derived. No responsibility can be
undertaken for occurring damages. Our products are subject to a continuous production and quality control and leave our factory in perfect condition.
ALBERT ROSE CHEMIE . In den Ziegelwiesen 6 . D-69168 Wiesloch . Telefon ++49 6222/578-0 . Telefax ++49 6222/578-132
Technical Information
ARCAGEL 125 D Blue
Page 2 of 2
Update: 26.10.15
DEVELOPING After approx. 5 minutes in the water bath at 15-20°C, rinse with clear water or
develop the screen in a screen developing machine.
HARDENING/ The dried screen will be cured for 30-60 minutes at 180°C. Ensure a uniform
CURING temperature (+/- 5°C) in the curing oven. Depending on the application, 1 h at
160°C can be sufficient.
RETOUCHING For retouching, retouch lacquers of our range of ESTELAN products are
suitable. Please contact your agent or ARC directly for further information.
Repair work on the printing machine can be done with the extremely fast
drying one-component lacquer ESTELAN 440.
VISCOSITY Approx. 5600 mPas (Rheomat RM 180, MS 33, D = 100 s-1, 23°C)
SAFETY ADVICE/ When working with ARCAGEL 125 D Blue, especially during coating, drying
ENVIRONMENTAL and curing, ensure good ventilation of the working area. Avoid skin contact.
PROTECTION
Please see further information given in the Material Safety Data Sheet.
STORAGE (20-25°C) Unsensitized: 18 months (in original container). Protect against frost.
Sensitized: approx. 7-10 days