Oana)
SGicu kcu es
type
=
|
tin
iene OIE,
+
3.9 Terminal Box
gh voles
Power ceurce must be asconnected before werk on
equipment.
Faure to daconneet pawer saute could est in inay
reat
Terminal box ony to be opened by skied personne
1) Description
Use the attached terminal box drawing in the inal
specification
‘The main terminal box of the machine I located on the
{op of the machine,
“The neutral and phase wires are connected tothe copper
‘bus bar-one copper bus bar per phase and one copper
‘bus bar per neutral line (option
‘See terminal box lagram inthe final specication
‘he openings provide access to te terminal.
‘he gland plates are made of non-magnetic materials in
‘order to avod circulating curents if needed
Compare the supply voltage with the data onthe rating
plate. Connect the supply leads and the links in
Accordance with the cut hagram inthe faa
specification.
Pay attention tothe right rection of rotation (phase
sequence inthe case of three phase and pola inthe
case of direct current,
‘The supply leads should be matched tothe rated current
Iintine with VOE0100 and ther cross section must not be
‘The main circuit s normaly connected at both sides of
the circuit bas with conductor cross sections of max.
300 mand may be made by cable lugs or when
‘connecting parts used in hazardous locations which are
present without any lugs,
‘The ends ofthe conductors should be striped in such a
\way that the remaining insulation almost reaches up to
the lug or terminal (<$ min,
In the case of cable lugs with fong sleeves, it may be
‘necessary to insulate the later to maintain the proper
clearances ina.
tf using cable lugs, see thatthe dimension of the cable
lugs and its fastening elements (normaly M12) agree with
the holes nthe copper bus bar,
‘Use hexagon-head eerowe with a min. broaking point of
500", hexagon nts and spring elements which are
protected against corrosion according to DIN 43673,
‘Te connection of accessories Is achieved by terminal
strips
Use a5 mm maximum screwdriver to work onthe
blocking sorews.
‘Se tv esi Comet ig ot i he a
specification
“The supply leads ~ particularly the protective conductor ~
should bela oosely in the terminal box with an extra
length for protecting the cable insulation against spitting
‘and to prevent the termina and circuit brs rom the
tension load ofthe leads,
‘They shouldbe introduced into the terminal box through
cable entry fitings and sealed,
Protected fittings with strain relief cleats shouldbe used.
{fo loose leads to prevent thom from becoming twisted.
Close off any unused cable-entry openings.
contre retucire Spcromere | A xMACANEAVY ADLHES = AT