Professional Documents
Culture Documents
2 Print Tips
2 Print Tips
Print tips
TIPS WHEN PRINTING AN OBJECT
Check out the the side view below with different positions of the first layer.
1 and 2: not good! The nozzle height calibration is set too low.
3 and 4: good! The nozzle height calibration is OK for both.
5: not good! The nozzle height calibration is set too high.
If you haven't 3D printed in more than two weeks, we would suggest you do the following
before you start printing again;
Check whether the print bed holder and hotend holder are still able to move smoothly.
If not, oil all rods but make sure the oil does not get in contact with the plastic
parts or the print bed
The BuildTak sticker may be greasy or dirty so make sure to clean the BuildTak
surface with a moist towel or detergent.
Check whether the filament on your spool hasn't caught too much dust. If so, clean
your filament or use new filament.
Article Number: 544 | Last Updated: Mon, May 29, 2017 10:18 AM