Professional Documents
Culture Documents
If you're having trouble with any of the assembly steps, you can either check out the 'Tips and
tricks' chapter or watch the full assembly video here!
1x FRAME BOTTOM
4x PLASTIC X ROD HOLDER
1x LCD SCREEN
2x M3 SPACER 15mm
4x M3x4 BOLTS
1x FRAME
8x PARKER 2,5 x 6mm
Now without further ado, let's start making the Vertex Nano!
Place all 4 x ROD HOLDERS into the 4 fitting square holes of the FRAME BOTTOM as shown
in the picture. Then secure the holders by using 4 PARKER SCREW 2,5 x 6mm and screwing
them through the top hole.
When in doubt about which screws, nuts, bolts or washers to use, please refer to one
of the following charts; Chart A. Chart B.
Attach 2 M3 SPACER 15mm onto the two top holes of the LCD SCREEN by using 2 M3 x 4
BOLTS. Note the orientation!
Place the FRAME BOTTOM upside down and place the LCD SCREEN assembly from step 2
onto the FRAME BOTTOM as shown in the picture. Make sure it is aligned, then attach
both parts by using 2 M3 x 4 BOLTS.
Insert the FRAME BOTTOM into the FRAME. Do not yet fix them!
Use 4 PARKER 2,5 x 6mm screws to attach the FRAME BOTTOM onto the frame. Make
sure the side of the FRAME overlaps the back of the FRAME as shown in the picture.
Article Number: 516 | Last Updated: Fri, Jan 13, 2017 4:54 PM