Professional Documents
Culture Documents
3. Which one of the listed requirements regarding the buoyant smoke signals doesn’t
correspond to present regulations? The buoyant smoke signals shall:
a) Emit smoke for at least 03 min when floating in calm water
b) Continue to emit smoke when submerged in 100 mm water for 10 seconds
c) Not be swamped in a seaway
d) Give a bright red light during emission time
7. Which of the following requirements do not correspond to present regulations? Liferafts shall:
a) Have all entrances fitted with rigid boarding ramps for boarding the life raft at sea
b) Have a floor preventing the ingress of water
c) Have a manually controlled lamp fitted inside the life raft
d) Have a manually controlled lamp visible for at least 02 NM fitted at the top of the canopy
8. Life raft canopy EXTERNAL light should be able to operate for at least hrs
continuously.
a) 04
b) 08
c) 12
d) 16
9. Life raft canopy external light should flash not less than & not more than flashes/
minute.
a) 20 & 50
b) 50 & 60
c) 50 & 70
d) 60 & 70
11. VHF EPIRB is designed for use in which GMDSS Sea Area?
a) Area A1
b) Area A1-A2
c) Area A4
d) None of the above
12. Which of the following equipment is not contained in a SOLAS Pack-B life raft?
a) Fishing-tackle+Food+Drinking water
b) Fishing tackle+Drinking water Bailer
c) Fishing tackle+Sea Sickness bags+drinking water
d) None of the above
13. As per regulations, a cargo ship of length less than 100 mtrs shall have at least lifebuoys
a) 06
b) 14
c) 12
d) 08
14. As per regulations, a passenger ship of length less than 60 mtrs shall have at least
lifebuoys
a) 06
b) 14
c) 12
d) 08
19. Which of the following is/are the SOLAS requirements for buoyant smoke signals?
a) Emit smoke for a period of not less than 03 minutes when floating in calm water
b) Not emit any flame during the entire smoke-emission time
c) Continue to emit smoke when submerged in water for a period of 10s under 100 mm of water
d) All of the above
20. Which of the following is/are the SOLAS requirements for Hand flares?
a) Have a burning period for not less than 01 minute
b) Burn with a luminous intensity of at least 15,000 candela
c) Continue to burn after having been immersed for a period of 10s under 100 mm of water
d) All of the above
21. Heliograph is useful to check the breathing of an unconscious patient in Lifeboat or Life raft.
a) True
b) False
22. Minimum two oars to be kept in an enclosed LB to make rowing of Life Boat possible.
a) True
b) False
24. Five litres of Drinking Water per person is provided in every Liferaft.
a) True
b) False
25. Life Boat engine can run for not less than 5 minutes with the L/B out of the water.
a) True
b) False
26. Fully Enclosed LB with Fire-protection system provides protection from Oil-Fires
for not less than 8 minutes.
a) True
b) False
27. Fall Prevention Devices (FPDs) are required to be fitted for Off-Load release system LBs _
a) True
b) False
28. Number of persons the life boat is approved to carry is to be written on every life boat
a) True
b) False
29. Passenger ships of 500 GRT and over must carry at least one rescue boat on each side.
a) True
b) False
33. Lifejacket lights should have battery power for at least 06 hours.
a) True
b) False
34. SART transmits return-signal when interrogated by X-band (3 cm wavelength) radar waves.
a) True
b) False
35. Fire Alarm can be activated automatically or by pressing the manual call point.
a) True
b) False
36. Liferaft with capacity of 08 persons or lesser, need two diametrically opposite entrances.
a) True
b) False
37. Immersion suits zippers should be lubricated with approved lubricants, for smooth operation.
a) True
b) False
38. SART battery should last for minimum 48 hours in stand-by mode, when not transmitting.
a) True
b) False
39. Liferaft canopy external light shall have minimum operating capability for 08 hours.
a) True
b) False