Professional Documents
Culture Documents
Report 3885
For the testing of “Melos and Fairmont EPDM Rubber slab” supplied by
“APT ASIA PACIFIC PTY LTD”
Contact:
James Tritt
Date of Receipt:
27/06//2018
Date of Test:
10/07/2018
Laboratory Director
Date
Date 10/07/2018
Grant Humphreys
The findings of this report can not be reproduced unless reproduced in full.
Checked By Date
Accredited for compliance with ISO /IEC 17025 - Testing.
The results of the tests, calibrations and/or measurements included in this document are traceable to
Australian/national standards. L4_19_F1 Issue 1
Page: 2 of 6
Report 3885
Product Description:
P3-15 Control A
Ecolastic play B
Ecolastic sprint plus C
P3-15 -1 Melos D
P3-15 -1 (FISB) E
P#-15-2 (FISB) F
Thick G
Archiving:
A sample of the material archived for future identification purposes, the remainder being discarded
Preparation:
Location of Testing: 44/59-69 Halstead St South Hurstville NSW 2221 Australia/ Site
Test Method
The sample was mounted in the Taber machine and run with the two wheels. H18 wheel and 1kg
load on each wheel at 72hz. The sample was weighted before testing and after testing. The
wheels where cleaned and re-faced with the wear disc before each test. The sample was run for
1000 cycle.
Checked By Date
Accredited for compliance with ISO /IEC 17025 - Testing.
The results of the tests, calibrations and/or measurements included in this document are traceable to
Australian/national standards. L4_19_F1 Issue 1
Page: 3 of 6
Report 3885
I = [(A - B) * 1000] / C
where I = wear index
A = weight (mass) of specimen before abrasion
B = weight (mass) of specimen after abrasion
C = number of test cycles
Requirements
There are no specification pass/ fail requirements. This test is a comparison between samples to
determine which is abrading fast or slower per number of cycles. This then works out the mass
loss or the wear index which allows the wear to be compared.
Results
Comments
Sample ‘Ecolastic sprint plus’ was wearing faster than the others.
Checked By Date
Accredited for compliance with ISO /IEC 17025 - Testing.
The results of the tests, calibrations and/or measurements included in this document are traceable to
Australian/national standards. L4_19_F1 Issue 1
Page: 4 of 6
Report 3885
Pictures of samples
Sample A
Sample B
Checked By Date
Accredited for compliance with ISO /IEC 17025 - Testing.
The results of the tests, calibrations and/or measurements included in this document are traceable to
Australian/national standards. L4_19_F1 Issue 1
Page: 5 of 6
Report 3885
Sample C
Sample D
Checked By Date
Accredited for compliance with ISO /IEC 17025 - Testing.
The results of the tests, calibrations and/or measurements included in this document are traceable to
Australian/national standards. L4_19_F1 Issue 1
Page: 6 of 6
Report 3885
Sample E
Sample F
Checked By Date
Accredited for compliance with ISO /IEC 17025 - Testing.
The results of the tests, calibrations and/or measurements included in this document are traceable to
Australian/national standards. L4_19_F1 Issue 1