Scribd Logo
Upload

Welcome to Scribd!

  • DOLEN

    Uploaded by

    Rochelle Siolao
    9 views1 page
    This C++ code defines functions to set up and loop digital outputs on pins 1, 2, 3, and 7 of an Arduino. The setup function sets the pins as outputs. The loop continuously cycles through pins 1-3, turning each pin on for 5 seconds while also generating a tone on pin 7, then turning the pin off for 5 seconds with no tone, before moving to the next pin.

    Original Description:

    Copyright

    © © All Rights Reserved

    Available Formats

    DOCX, PDF, TXT or read online from Scribd

    Did you find this document useful?

    Is this content inappropriate?

    Report this Document
    This C++ code defines functions to set up and loop digital outputs on pins 1, 2, 3, and 7 of an Arduino. The setup function sets the pins as outputs. The loop continuously cycles through pins 1-3, turning each pin on for 5 seconds while also generating a tone on pin 7, then turning the pin off for 5 seconds with no tone, before moving to the next pin.

    Copyright:

    © All Rights Reserved
    Download as DOCX, PDF, TXT or read online from Scribd
    Flag for inappropriate content
    9 views1 page

    DOLEN

    Uploaded by

    Rochelle Siolao
    This C++ code defines functions to set up and loop digital outputs on pins 1, 2, 3, and 7 of an Arduino. The setup function sets the pins as outputs. The loop continuously cycles through pins 1-3, turning each pin on for 5 seconds while also generating a tone on pin 7, then turning the pin off for 5 seconds with no tone, before moving to the next pin.

    Copyright:

    © All Rights Reserved
    Download as DOCX, PDF, TXT or read online from Scribd
    Flag for inappropriate content
    of 1

    NAME: DOLENA Q.

    GUMAPON YEAR/SECTION: BSIT-3A

    // C++ code
    //
    void setup()
    {
    pinMode(1, OUTPUT);
    pinMode(2, OUTPUT);
    pinMode(3, OUTPUT);
    pinMode(7, OUTPUT);
    }

    void loop()
    {

    for(int i=1;i<=3;i++)
    {

    tone(7,15);
    digitalWrite(i, HIGH);
    delay(5000); // Wait for 1000 millisecond(s)
    noTone(5);
    digitalWrite(i, LOW);
    delay(5000); // Wait for 1000 millisecond(s)
    }

    You might also like