Professional Documents
Culture Documents
Op nbr 646-003
This operation also includes required tools and times for applicable parts of the following operations:
1. Remove the nuts from the damping cylinder. Remove the connection that is in the way.
Figure 1
2. Remove the damping cylinder and check that the springs are intact.
Figure 2
3. Replace the damping cylinder seals. See Damping cylinder, changing seals.
4. Assemble the damping cylinder. Fill the space around the cup springs with grease.
6. Remove the nut again and check the measurement (pre-load) between the guide and the cylinder using a sliding
caliper.
For the right pre-load, see Damping cylinder, specification.
Figure 3
Figure 4
9. Press the seals into place by pressurising the damping cylinder. See Damping cylinder, changing seals.