Professional Documents
Culture Documents
plugin 462,508
https://ecu.design
PHOENIX L11 JOHNDEERE
DIRECT CONNECTION
In order to connect to the ECU use the CABLE F32GN037C/D.
Make sure that the POWER led (red) on Trasdata is ON.
ECU CONNECTOR
https://ecu.design
PHOENIX L11 JOHNDEERE
BOOT/POL4 CONNECTION
Connect the GREY wire of the cable F32GN037C/D as described here below :
RX & TX CONNECTION
To connect the RX & TX communication lines it is necessary to use the FLAT CABLE F34NTF53
https://ecu.design
PHOENIX L11 JOHNDEERE
https://ecu.design