The document provides guidelines for the taking over, storage, installation, maintenance, and replacement of bearings for road design and construction. It states that bearings must be undamaged and properly fabricated, and installed, maintained, and replaced if needed by qualified personnel. When taking over bearings, checks must be performed to ensure no visible damage, proper cleanliness, conformity with design, correct designations and dimensions, and appropriate pre-adjustment levels and directions. Special instructions from suppliers, contractors, engineers or carriers take precedence over these guidelines.
The document provides guidelines for the taking over, storage, installation, maintenance, and replacement of bearings for road design and construction. It states that bearings must be undamaged and properly fabricated, and installed, maintained, and replaced if needed by qualified personnel. When taking over bearings, checks must be performed to ensure no visible damage, proper cleanliness, conformity with design, correct designations and dimensions, and appropriate pre-adjustment levels and directions. Special instructions from suppliers, contractors, engineers or carriers take precedence over these guidelines.
The document provides guidelines for the taking over, storage, installation, maintenance, and replacement of bearings for road design and construction. It states that bearings must be undamaged and properly fabricated, and installed, maintained, and replaced if needed by qualified personnel. When taking over bearings, checks must be performed to ensure no visible damage, proper cleanliness, conformity with design, correct designations and dimensions, and appropriate pre-adjustment levels and directions. Special instructions from suppliers, contractors, engineers or carriers take precedence over these guidelines.
Guidelines for Road Design, Construction, Maintenance and Supervision Bearings
Figure 5: Schematic presentation of interdependence of structure and bearings
10. TAKING OVER, STORAGE,
INSTALLATION, MAINTENANCE, The bearing installation drawing, all AND REPLACEMENT OF certificates, licences, eventual special BEARINGS instructions, and the record of bearing shall be permanently available on the construction An adequate supporting can be achieved by site. installing undamaged and properly fabricated bearings, by their maintenance and, if 10.1 Taking over of bearings required, by their replacement as well. Upon taking over of the bearings, the In case that no special instructions by the following shall be checked: bearing supplier, contractor, supervising - eventual visible damages, in particular of engineer or carrier are available, the corrosion protection; provisions of this design standard shall be - cleanliness of bearings; taken into consideration. - conformity with the bearing design; - bearing designations; Transportation, provisional storage, and - bearing dimensions; installation of bearings shall be carried - magnitude and direction of pre-adjustment; through only by specially appointed and - possibility of subsequent modification of qualified labour. pre-adjustment.
RS-FB&H/3CS – DDC 433/94 Volume 1 - Section 2 - Part 6 Strana 19 od 21