Professional Documents
Culture Documents
MB10
1.2 SCOPE
This manual provides detailed installation and operation instructions for the PS Engineering MB10-series
of Audio Selector Panel/Intercom Systems. This includes the following units:
Model Description Part Number
MB10 Marker Beacon Receiver w/Indicator 050-023-0100
MB10R Remote (Blind Mounted) Marker Beacon Receiver 050-023-0101
1.5 SPECIFICATIONS
TSO COMPLIANCE
Marker Beacon: C35d, Class A
APPLICABLE DOCUMENTS: RTCA/DO-143 RTCA/DO-160E
ENVIRONMENTAL Qualifications: B2D1CABSMXXXXXXZBABATBXXE2XXX
Operating Temperature Range: -45 C to 55ºC
Altitude: Up to 50,000 feet in an non-pressurized area
DIMENSIONS: Dimensions: 0.95" H X 2.8" W X 4.85" D
(2.2 cm x 6.6 cm x 12.3 cm)
WEIGHT
MB10 Unit & connector 6.5 Ounces (.18 kg)
POWER REQUIREMENTS (Including Internal Lighting):
Voltage: 11 to 33 VDC
Maximum Current: 0.25 Amp (Externally protected by a 1.0 A break-
er)
Section II - Installation
2.1 GENERAL INFORMATION
2.1.1 SCOPE
This section provides detailed installation and interconnection instructions for the PS Engineering MB10
Marker Beacon system.
Please read this manual carefully before beginning any installation to prevent damage and post-installation
problems. Installation of this equipment requires special tools and knowledge.
2.1.2 Certification Requirements
NOTE
The MB10 requires specialized knowledge, tools and test equipment for an effective in-
stallation. An appropriately rated Certified Aircraft Repair Station must install this
equipment in accordance with applicable regulations. PS Engineering, Incorporated war-
ranty is not valid unless the equipment is installed by an authorized PS Engineering, In-
corporated dealer.
Failure to follow any of the installation instructions, or installation by a non-certified in-
dividual or agency will void the warranty, and may result in an unairworthy installation.
2.5 Adjustments
The MB10 is factory adjusted to accommodate the typical requirements for most aircraft configurations.
There are three adjustments in the top cover that allow the installer to tailor the specific functions.
Adjustment rotation to
INCREASE levels
3.1 SCOPE
This section provides detailed operating instructions for the PS Engineering MB10, Marker Beacon system.
Please read it carefully before using the MB10 so that you can take full advantage of its capabilities.
Instrument Panel
4.97 in
4-40 screw x 2
6.47 in
0.85in
Ø0.166in
0.43in (3x)
0.06in
0.95in*
(3x)
2.13in
2.77in*
6.98 in
3.25 in
3.25 3.75
4.95 in
Ø0.14 in
4 places
0.95 in
2.28 in
Figure 5-3 Remote Mounting with 430-023-0030 (x2) flanges. Not to Scale
8 7 6 5 4 3 2 1
15 14 13 12 11 10 9
Marker Audio Output
OM Lamp Output
MM Sense Output
14 V Lights Hi
IM Lamp Out
Remote Hi Sense
MM Output Active Lo
OM Output Active Lo
POWER GROUND
Marker Audio Ground
Remote Test/Mute
IM Output Active Lo
9 Aircraf t Ground
6 Marker Audio Hi
Audi o Sys tem
14 Marker Audio Lo
13 Remote Test/Mute
15 Remote Hi Sens e
Note2
MKR Ant.
Female BNC
7 14 V Dimmer Input
on unit
8 28 V Dimmer Input