Professional Documents
Culture Documents
ASP WARNINGS
1 Bulk configuration install failed. Configuration installation failed when the user try to save configuration.
Should use the latest FM, where encrypted config file is sent
2 Config corrupted and settings in SF loaded. Config in dataflash corrupted and config loaded from serial flash.
5 Pump failure 1. 4R+ sensor not installed properly and leaks will be there
2. Filter is not present at the inlet
6 Toxic 1 Sensor reflex test is failed CO sensor contact issue or sensor failure
7 Toxic 2 Sensor reflex test is failed H2S sensor contact issue or sensor failure
12 Stuck at fault for sensor3 H2S sensor contact issue or sensor damaged
13 Stuck at fault for sensor4 LEL sensor contact issue or sensor damaged
14 Stuck at fault for sensor5 RAE sensor contact issue or sensor damaged
24 Rae Eeprom Wrong part number Bad sensor. Should replace the sensor
25 Invalid RTC Power failure to RTC. Should set the time again
ASP - ERRORS
26 Error was caused by a fatal assertion Many failures. Need to read ASP devicelog for routecasuse
32 Sensor configuration not valid Baseline and Sensitivity might be not in limits
38 All sensors stuck at fault and not running If all sensors failed with stuck at fault
40 Data flash Test failed 24 hr test : configuration file in data flash is corrupted
42 Supply voltage test failed Controller supply voltage failure. Controller supply should be with in 1.6
to 3.6 V
ICM - WARNINGS
132 ICAP: Max chunk size for comm Wrong configuration file
140 ICAP: factory config file install fail Configuration file corrupted
141 SELF_TEST: Event log CRC Failure Serial flash Memory corruption
142 SELF_TEST: Bump log CRC Failure Serial flash Memory corruption
143 BLE: Flash Init Failure BLE module connection issue or wrong firmware loaded
150 IR: Rx Over run error Wrong data from Fleet manager
151 IR: UART Not Ready Wrong data from Fleet manager
156 No valid sensor installed on device Sensors not installed. Configuration issue
157 FW image CRC fail Wrong Firmware file received
162 - NFC: NA
165
ICM - ERRORS
188 No broadcast data received from ASP Communication error from ASP
192 DBG task did not respond to prod signal Operating system failure
193 ICM task did not respond to prod signal Operating system failure
194 LOG task did not respond to prod signal Operating system failure
195 BLE task did not respond to prod signal Operating system failure
196 IR task did not respond to prod signal Operating system failure
197 IPC task did not respond to prod signal Operating system failure
198 SEH task did not respond to prod signal Operating system failure
199 WDT task did not respond to prod signal Operating system failure