Professional Documents
Culture Documents
Page 1
Folding Picnic Table Plans – Overview
Page 2
Folding Picnic Table Plans – Material List
2 1/2″ deck screws 8 – 2×4 – 1′ 4″ (15-degree angle cuts on both ends in the same direction)
2 – 2×4 – 5′ 3″
16 – 2×4 – 6′
Page 3
Build two bench frames as shown above. Cut four 2×4’s to 5′ 6″ long, and six 2×4’s to 10 3/4″ long.
Assemble as shown on illustration above using 2 1/2″ deck screws.
Cut eight 2×4’s to 1′ 4″ long for the bench legs, cut 15-degree angle cuts on both ends in the same
direction, see illustration above.
Page 4
Install the legs to the bench frame as shown on illustration above using 2 1/2″ deck screws.
Cut four 2×4’s to 1′ 5″ long for the bench leg brace. Cut 15-degree angle cuts on both ends in opposite
directions, see illustration above.
Page 5
Install the leg brace as shown on illustration above, screw 2 1/2 deck screws through the brace and into
the legs.
Cut two 2×4’s to 5′ 3″ long for the bench support. Install as shown on illustration above, screw 2 1/2″
deck screws through the leg brace and into the bench support.
Cut eight 2×4’s to 6′ long for the bench top slats. Gap the slats about 1/4″, the ends of the bench seat
slats will have a 1 1/2″ overhang, the front and back will have a 1/2″ overhang.
Page 6
Cut four 2×4’s to 1′ 2 3/4″ long, cut 45-degree bevel cuts to the ends as shown on illustration above.
Install the 2×4’s to the bench slats as shown on illustration above using 2 1/2″ deck screws.
Page 7
Cut the parts for the table frame as shown below.
(A) Cut four 2×4’s to 1′ 3 1/2″ long, cut 15-degree bevel cuts on both end in same directions.
(B) Cut four 2×4’s to 7 1/2″ long, cut 15-degree bevel cuts on both end in same directions.
(C) Cut four 2×4’s to 5 1/2″ long, cut 15-degree bevel cuts on both end in same directions.
(D) Cut four 2×4’s to 10″ long, cut a 15-degree bevel cut on one end.
Page 8
Assemble four table frames as shown on illustration above using 2 1/2″ deck screws.
Page 9
Cut eight 2×4’s to 6′ long. Gap the table slats about 1/4″ gap and install as shown above using 2 1/2″
deck screws. The table slats will have a 1 1/2″ overhang on the sides.
Page 10
Bring both pieces together to form the table.
Page 11