item
as
|Specification
Manufacture
Proccess of Manufacture
SURYA ROSHNI LIMITED
Technical Data Sheet
: ERW Pipes
1S 1239 (Part-1)
:SURVA ROSHNI LIMITED (Anjar), INDIA |
+ ELECTRIC RESISTENCE WELDED (ERW)
Dste-30.03.2023,
S.No. Characteristic Description. Remark
1) frtansfacture Surya Roshal Limited, Trade MARK Prakash Surya
2} |Applicable Specification Is 1239(Pare-1}:2004 i
F [RM Supplier
3) |steat ie oils confirming to 1:10748 Gr-2 laninstessamy(ssw/TATAY
sai.
4) [size sone & 100N8 Gt,
5) |etass eave
6) outside diameter [aS PER 1S:1239 (2004)
7)_|Wallthickness -10% of specified WT /+ N.S. (FOR HEAVY)
8) [weight [as PER 1S:1239 (2004)
9) straightness |as PER IS:1239 (2004)
As per WO/PO requiremet or Al pipe canbe supaled with inthe length
10) standard Length ie
11) Pine Ends Plain Ends i
12) [chemical analysis [As PER 1S:1239 (2004)
13) | mechanical Testing Jas PER 18:1239 (2004) 1
When tasted in aecardance with 15 2579 the tubes shall be capable of
withstanding the bend tet without showing any signs of fracture or
‘Welded tubes shall be bent withthe weld at 90 degree tothe
ending. The tubes shall be not be filled for ths test
14) [bend Test |Gaivanizag tubes shall be capable of bending bent co, without
lraking of the steel, through 90 degree round 2
Jcrmer having a radius atthe bottom of the groove equal to
lat leat ight timer the outede clameter of the tubes.
Ringe not les than AOrim I Tengih eat Wom the ends of he selected
lubes shall be flattened cald between parallel plates withthe weld, if
any at 90 degree (point of maximum Bending) In aczordance with IS
2328.No opening shall be occur by fracture in the weld area until the
15) |riateing Tet distance betweun the plates is less tha 75% of the orginal OD of the
lube and no cracks or breaks inthe metal elsewhere than in the weld
shall occur until the distance between the plates is less than 60
percent ofthe original 0D.
Hydrostatic test shall be carried out at a pressure of SMDpa at the same
ab], senate Bete maintaned for atleast 3 and shall not show any leakagein the pipe.
17) |Surface protection (as per PO requirement)
Hot dip Galvanized
Inne Zine coating on the tubes shall bein Accordance with IS: 4736,
las PER 1S:1239 (2004)
_
PREPARED)
on
CEES
APPROVED BY