To start off, water is needed for the humidifier to be able to
start and vent moisture into the air. The solenoid valve is used to control the flow of the water so it may let it enter when there is enough.when the Solenoid valve allows water to enter, the water goes into a drip emitter, which results in small drips of water to moist the air. Thanks to a blower motor, it’s job is to blow air through the drive belts and the recirculating blower and push the drops of water from the drip emitter down the tube so it can be distributed into the warehouse . Water that is not fully blown to moisture the air, go into the drain line to exit the building. The moist air from the drip emitter is then in the air and some of it is used to help the air flow with the water that’s being dropped and being blown by the blower motor. The moist air that has reached the warehouse is then sampled at the bottom and enters a sampling chamber with a wet and dry bulb that are used to see and control the temperature to properly vent the air out and when the air is good, it is vented out by using an air blower.