Cairo University Duration 1 hr
Faculty of Engineering MDP2140
Mechanical Design and Production Department March 2023
NAME: SEC.: B.N.:
loose the best answer(s) (10 points
‘Why designs are periodically modified?
a) to strive for zero-based rejection and waste
fo make products easier and faster to manufacture
0 improve product performance
) all of the mentioned
rotating shaft has infinite number of critical speeds.
, conceptual design is defined
enance and cost
ity and performance
d Drawings
Detailed design
tional drawings.
Page 1of 6
CamScanner + lig do sucall7. Superposition method can be used to estimate shaft diameter.
a) True
b) False
8. Why preliminary design phase is required?
‘a) ensure elements dimensions
b) enable construction drawing
¢) define design concept
d) all of the mentioned
9, For manufacturing a shaft that transmits a power. What will be the factor of safety
in the preliminary design phase
a)FS>2
b)F.S=2
c)FS<2
d)FS>1
10.What results will be obtained from detailed design phase?
__ a) Final Dimension
b) Accurate safety factor and lifetime
Design concept definition
Accurate constructional drawings
nce is a phenomenon that occurs only in shafts.
in constructional drawing
CamScanner + Lis do sucallFrequency is the speed at which the rotating shaft becomes dynamically
le.
leigh and Dunkerley Equations can predict the maximum natural
y of a rotating shaft.
igidity means to design using superposition technique.
phase is not important if the shaft is designed against fatigue
le proper way to transmit torque in manual gearboxes.
ion of Interference fit.
backlash is needed.
CamScanner + Lis do sucallProblem (15 points):
The shaft shown in figure carries two flat belt pulleys (1&2) by two bearings
(A&B). Due to construction integrity, the maximum deflection should not
exceed 0.05 mm at the pulleys. Complete the tables with your answers.
N
CamScanner 2 Lis d sual!Static Analysis (using MSST):
ie Analysis:
Deflection Analysis:
Due to Pulley 1:
ou=
Oa =
Due to Pulley 2:
One
622=
For the whole shaft:
Page 5 of 6
CamScanner + Lis dsucallclusions and Recommendations (5 points)
SAFE NOT SAFE
ic Analysis
ing MSST)
tigue
alysis
Recommendations
60f6
CamScanner + lis. i> sual!
=