Professional Documents
Culture Documents
Midterm Assessment in Epas - 12: Schools Division of Bulacan
Midterm Assessment in Epas - 12: Schools Division of Bulacan
Department of Education
Region III- Central Luzon
Schools Division of Bulacan
Directions: Read and analyze the following questions. Choose the letter of the best answer.
1. It refers to the practice of going through all the tools, materials, etc.
a. simplifying c. standardizing
b. Sorting d. sweeping
2. An electronic device that receivers radio waves and converts the information carried by
them to a usable form.
a. light emitting diode c. transmitter
b. television d. radio
6. Which of the following needs to be checked before assembling and disassembling a CCTV
system with hand tools?
a. Select faulty hand tools
b. Examine and clean the hand tools
c. Check defective hand tools to be used
d. Never use personal protective equipment
8. Which of the following statements about utilizing a service manual in repair is correct?
a. for application c. used as references
b. used as warranty d. all of the above
9. Which of the following CCTV camera types has the best indoor and outdoor compatibility?
a. bullet CCTV c. dome camera
b. c-mount CCTV d. infrared CCTV
10. Which of the following is the main objective of waste electrical and electronic equipment?
a. The environmental performance of individual.
b. The administrative burden by calling for the harmonization of national registers and of
the reporting format.
c. Requires the combination of collection and treatment of WEEE and sets targets for their
collection as well as for their recovery and recycling.
d. Contributing to the efficient use of resources and the retrieval of
secondary raw materials through re-use, recycling, and other forms of
recovery.
11. What is the most important criteria in installing consumer electronic products?
a. The work site is not cleared of all debris.
b. Materials necessary to complete the work are obtained.
c. Devices are not tested in accordance with standard procedures.
d. inspections are undertaken to ensure that the installed devices conform to technical
requirements.
12. Which of the following signal strengths does the radio receiver?
a. The range depends on the power of the transmitter.
b. The static of the receiver, atmospheric and internal noise.
c. Radio waves increases.
d. Range is depending on ground waves
14. What will happen to the screw if you over-tighten them with a screwdriver?
a. stuck c. not tightens
b. exposes d. all of the above
15. Filtered and amplified radio signals are used. How the receiver decodes the information-carrying
modulation signal
a. amplitude c. rectification
b. detector d. transducer
21. What occurs when your electric guitar is connected to a basic karaoke amplifier?
a. Amplify signal c. Destroy the pre-amp.
b. Distorted sound d. Feedback on the signal
22. Which of the following is the main stage of a radio receiver?
30. Which of the following is the sequence of a tuned radio frequency (TRF) receiver?
I. radio frequency III. Audio amplifier
II. demodulator
32. Leandro has an electronic repair shop. The customer has an amplifier to be repaired. Leandro
finds out there is a blown resistor. How did Leandro determine the value of the resistor
whose color was green, red, yellow, and gold?
a. The value is 42 ohms ±5%, as calculated using a resistor color coding table.
b. The value is 52 ohms ±5%, as calculated using a resistor color coding table.
c. The value is 62 ohms ±5%, as calculated using a resistor color coding table.
d. The value is 520k ohms ±5%, as calculated using a resistor color coding table.
33. Which of the following radios is used for entertainment while driving?
a. car radio c. satellite radio
b. portable radio d. table radio
37. Which of the following is powered by batteries and can be carried by a person?
a. car radio c. satellite radio
b. portable radio d. table radio
38. Which of the following is necessary to find the faulty component in the multistage amplifier?
40. Mark Carlo has a portable radio that he can carry to work; he likes listening to music while at
work. What ranges of frequency did he select?
a. AM 148 and 283 kHz c. FM 88 MHz – 108 MHz
b. AM 526 and 1706 kHz d. 30 MHz to 299 MHz
42. Which devices will be needed to connect numerous cameras to a single power outlet?
a. CCTV camera c. digital video recorder
b. centralized power supply d. TV monitor
43. Which of the following statements demonstrates proper tool storage practice?
a. Use bins for storing small parts.
b. Parts should be correctly stored and labeled.
c. Putting the blame on the person in-charge for storing tools and parts.
d. Tools should be correctly placed anywhere on board and without labels.
44. Which of the following statements shows a successful tool and equipment maintenance
program?
a. Use bins for storing small parts.
b. Well organized and scheduled.
c. Ensuring that maintenance is performed, as necessary.
d. Retaining records of maintenance/ service conducted.
47. What would result if the negative charge of the audio amplifier was connected to the chassis?
a. Avoid humming sounds.
b. Feedback sound
c. Short circuit
d. The whole chassis became grounded.