Professional Documents
Culture Documents
LEANOX SYSTEM
narendra PT NAVIGAT
ENGINE TYPE 4
EMISSION VALUES.
EMISSION VALUES.: Air Fuel ratio versus NOx,
NOx, CO,NMHC
narendra PT NAVIGAT
ENGINE TYPE 4
Leanox® controller
The operation of GE Jenbacher gas engines has been
optimised to ensure that lowest exhaust emission values
are achieved under full-load operation.
These optimised exhaust emissions can only be achieved
by operating lean-mix engines with the correct air excess
ratio λ (air ratio).
This principle exploits the direct link between NOx-
emissions and the air excess ratio to achieve minimum
exhaust emissions values.
narendra PT NAVIGAT
ENGINE TYPE 4
narendra PT NAVIGAT
ENGINE TYPE 4
Leanox® controller
The patented LEANOX control system is based on the
linear relationship between the air excess ratio and the
quantities power, boost pressure and air-gas mixture
temperature.
A control system based on these principles has the great
advantage that all these quantities can be measured
easily and reliably, and that the air ratio λ can be
calculated exactly.
No measuring probes that could be subjected to ageing
are required in the exhaust system. In this way the
emissions targets can be met reliably.
narendra PT NAVIGAT
ENGINE TYPE 4
narendra PT NAVIGAT
ENGINE TYPE 4
Leanox® controller
The task of the LEANOX controller is to calculate and set
the optimum boost pressure, based on the current power
output and the current air-gas mixture temperature.
The linear relationship between these quantities is
calculated automatically by dia.ne (SAM) after two of the
operating points have been stored to memory.
The LEANOX controller switches itself on automatically
once the actual power output exceeds a threshold value
(approx. 30% of the total power output). The program
provides four sets of parameters for different types of fuel
gas.
narendra PT NAVIGAT
ENGINE TYPE 4
narendra PT NAVIGAT
ENGINE TYPE 4
Leanox® controller
The LEANOX controller is always active during grid
interconnection operation, but can also be switched on
during isolated operation (depending on the system-
specific design).
A PI-controller is used for the actual controlling. The
actuator is a stepper motor, and it adjusts the gas
aperture at the air-gas mixer to control the air ratio λ.
narendra PT NAVIGAT
ENGINE TYPE 4
narendra PT NAVIGAT