Professional Documents
Culture Documents
WATERPROOFING SYSTEMS
• In the insulation of foundations and curtains, 12 cm, be solid and have a slope of 2%.
• On solid surfaces based on gross concrete, screed, plaster and cement, • Before filling the foundation pit of QIS BITUMAX 2K, it should be protected
• It is used in the repair of old bituminous membranes. from impacts during filling with appropriate drainage plates and thermal
CHARACTERISTICS insulation plates. The drainage plates should be connected to the drainage
• It has high elasticity and crack covering capacity. pipes and the water likely to be filled into the foundation pit should be
• It does not contain solvents or harmful substances, it is ecological. drained.
• It does not prevent the passage of water vapor. • Multi-porous, distorted or perforated surfaces should be stripped with QIS
• Jointless coating is applied. BITUMAX 2K to prevent air bubble formation and/or to smooth the surface.
• It has a high adhesion strength. • Especially in applications made in hot weather, the increase in consistency
• It provides precise insulation against soil moisture, moisture, water and that may occur during the usage period due to rapid water loss can be
pressurized water. eliminated by adding water in a rate not exceeding 3% of the material amount.
• It is resistant to chlorine, sulfate, salt solutions, weak acids and substances The water added material should be used after mixing homogeneously.
found in normal soil. • In exterior applications, the surface must be protected from strong wind and
• It is resistant to freeze-thaw cycle. frost for the first 48 hours. The product should not come into contact with
• It can be used on horizontal and vertical surfaces. water (at +20°C) until it has dried completely on the surface (2 days).
• Water inflatable tapes or PVC water retaining tapes should be used for cold
APPLICATION METHOD joint insulations at foundation and wall joints before application.
Surface Preparation • QIS BITUMAX 2K should not be applied on metal surfaces.
• The surface to be applied should be dry and clean. It should be free from
anti-stick substances such as dust, oil, paint, curing. CONSUMPTION
• Mortar residues, loose floors have to be cleaned, cracks and broken areas Against unpressurized water: 3.0 kg / m2 (2 mm of thickness)
have to be repaired and the surface level has to be leveled. Against pressurized water : 4.5 kg / m2 (3 mm thickness - mesh application)
• The corners and edges should be chamfered with a minimum radius of 4 cm. PACKAGING AND STORAGE
Lining 30 kg SET
• The surface should be primed with QIS BITUM ASTAR (BITUMEN PRIMER). Component A: 22 kg of bitumen liquid Component B: 8 kg of cement powder
• For priming, 1 kg QIS BITUMAX 2K can also be applied as a primer to the In its original packaging, when stored in ventilated, dry and protected environ-
surface by mixing with 400-600 rpm mixer with 4 lt water. ments at +5°C/+25°C, protected from sun, rain and frost, its shelf life is 1 year
• After the primer is dried, it is started to be applied. from the date of manufacture.