Professional Documents
Culture Documents
Page 6
Course Progression Map: Engineer OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
ENGINEER
Suggested no of
experience
years of
OPERATIONS MAINTENANCE
MECHANICAL & INSPECTION
EXPLORATION & PRODUCTION PROCESS & ANALYTICAL ELECTRICAL INSTRUMENTATION
STATICS INSPECTION ROTATING
✓ P&ID & Schematic Diagram ✓ Tankage and Storage ✓ Introduction to Piping ✓ Integrated Module ** ✓ DOMI Pump ✓ Protection Relay & Coordination ✓ Fundamental of Integrated Control
✓ Well Operation & Maintenance ✓ Piping and Valves System ** (general inspection) ✓ DOMI Gas Turbine ✓ Generating Equipment & System Safety System (ICSS)
✓ Heat Exchanger Operation & ✓ Downstream Plant Familiarisation ✓ DOMI Static ✓ Welding Technology ✓ DOMI Compressor & ✓ Basic Application of Ex Equipment in Hazardous ✓ Process Measurement I
Maintenance ✓ Plant Start-up & Shutdown Equipment ** ✓ Flange Management Blowers Area ✓ Control Valve
✓ Hydrocarbon Treatment System ✓ P&ID & Schematic Diagram (cover all statics ✓ Condition Monitoring ✓ High Voltage Switching and Generator ✓ Quality Measuring Instrument
✓ Basic Petroleum Prod, Transportation ✓ Distillation Principles (Pilot Plant and CBT) equipment) Equipment Synchronising Practice ✓ Vibration Monitoring System
& Processes ✓ Water and Wastewater Treatment System ✓ Pressure Relieving ✓ ASNT UTTM ✓ DOMI Rotating Equipment ✓ Portable Equipment and Temporary Installation ✓ Gas Detection System
✓ Oil and Gas Terminal Operation ✓ Pump Operation and Care Devices ✓ Single Stage Centrifugal ✓ Condition Monitoring and Maintenance of HV ✓ Introduction to the Distributed Control
✓ Separator Operation ✓ Heat Exchangers: Operation and Care ✓ Lifting and Rigging ** Pump Switchgears and Transformers System (DCS) Operation -ExperionPKS
✓ Gaslift Operations and Optimisation ✓ Plant Monitoring & Optimisation ✓ Valves and Safety ✓ Alignment Principles & ✓ Maintenance and Troubleshooting of LV Motors for Process Operator
✓ Wellhead and Production Header ✓ Piping and Valves Valves Maintenance & Technology (AC/DC) ✓ Introduction to the Distributed Control
System
✓ Gas Compression and Compressor
✓ Furnace
✓ Tankage and Storage
Repair
✓ Tank Maintenance**
✓ Mechanical Seal
Maintenance and
✓ Generator Operation & Control System
✓ Low Voltage Switchboard & Switchgear Equipment
System (DCS) Operation -Yokogawa CS
3000 for Process Operator
Legend:
Operation & Control ✓ Plant Process Troubleshooting (L2) ✓ Flange Management Troubleshooting Operation & Maintenance ✓ Plant Process Control & DCS System
1-3 years
BASIC
✓ Gas Dehydration and Regeneration ✓ Compressor, Fan and Blowers: Operation ✓ Reciprocating Compressor ✓ Maintenance and Troubleshooting of AC & DC Ups Operation
Programme is
System
✓ Petroleum Liquid and Gas Properties
and Care
✓ Heat Exchangers: Operation and Care
✓ Positive Displacement
Pump
System
✓ Testing, Pre-commissoning and Commissioning of
✓ Process Control Theory and Application
✓ Instrumented Safeguarding System ** available upon
✓ Crude Separation and Crude/ ✓ Water and Wastewater Treatment System ✓ Precision Practical Electrical Equipment ✓ Liquid and Gas Metering
Condensate Stabilisation ✓ Distillation Principles (Pilot Plant and CBT) Alignment ** ✓ HV System Switching ✓ Safety PLC-Tricon TMR
request
✓ Produced Water Treatment System On ✓ Tankage and Storage ✓ Electrical Protection System ✓ Programmable Logic Controller -Allen
The Platform ✓ Piping and Valves ✓ IQ Motor Operated Valve (MOV) Bradley CLX5000
✓ Water Injection System ✓ Furnace ✓ Selection, Installation and Inspection of Ex ✓ PID Tuning Professional
✓ Pipe, Valve, Fitting & P&ID ✓ Gas Turbine: Operation and Care Equipment in Hazardous Area ✓ Honeywell EPKS Engineering & Development
✓ Watermaker Operation & Maintenance ✓ Heat Exchangers: Operation and Care Maintenance
✓ Water and Wastewater Treatment System Programme (PDP)
✓ International Well Control Forum ✓ Distillation Principles (Pilot Plant and CBT) ✓ IECEx Unit Ex001 Competency Training
(IWCF) Well Control, L2 ✓ POTCP 01 -Distributed Control System Programme ✓ Certified Personnel for Metering
✓ International Well Control Forum (DCS) ✓ A0 Chargeman Validation & Calibration Competency
(IWCF) Well Control, L4 ✓ POTCP 02 -Process Control Programme Assessment &
✓ International Associate of Drilling ✓ POTCP 03 -Process Troubleshooting ✓ Instrument Fitter
Contractor (IADC) WellSHARP, L4 ✓ POTCP 04 -Plant Operation Practice
Certification
✓ POTCP 05 -Process Safety Practice Programme (A&C)
INTERMEDIATE
✓Plant Monitoring & Optimisation ✓DOMI of Piping System ✓Non Destructive ✓ Reciprocating Compressor ✓A4 Chargeman
✓Plant Process Troubleshooting & Valve Testing Level 2 ✓B0 Chargeman
✓Fundamental of Drilling Operation L2 ✓DOMI of Static (Fire) - ✓Flange Management ✓ Positive Displacement ✓Low Voltage Overhead Lines
4-8 years
✓Wellhead Preventive Maintenance L2 boiler fire equipment ✓Welding Inspection Pump ✓Low Voltage Generator and Synchronising
** ✓ Diesel Engine : Operation ✓IECEx Unit Ex001 & Ex003 Competency Training
✓Welding Technology & Maintenance Programme
✓Non Destructive ✓ Gas Turbine Operation & ✓IECEx Unit Ex007/008 Competency Training
Testing Maintenance Programme
✓Flange Management ✓ Pump Troubleshooting ✓IECEx Unit Ex001 & Ex009 Competency Training
Programme
ADVANCED
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 7
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
Course Progression Map: Engineer OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
ENGINEER
HEALTH, SAFETY & ENVIRONMENT
✓ PCSB PTW Level 2 Certification ✓ Safe Handling of Chemicals (SHOC) ✓ RA Tools Training (BowTie, HAZID, ✓ AGT for Non-Confined Space ✓ BASEL Convention
Programme ✓ Hearing Conservation Awareness HAZOP, P-HAZOP and PASR ✓ Basic First Aid (Knowledge Level) ✓ Environmental Management Awareness
✓ PCSB PTW Level 3 Certification Application ✓ Job Hazard Analysis (JHA) ✓ CePSWaM Field Training Report Preparation
Programme ✓ CePSWaM ✓ Mercury Awareness Workshop (FTR) _KL
✓ Authorised Entrant and Standby Person for ✓ CePSWaM Field Training Report Preparation
Confined Space (AESP) - Level 1 Workshop (FTR)
✓ Authorised Entrant and Standby Person for ✓ Handling of Scheduled Waste
Confined Space -Refresher (AESP) - Level 1
Legend:
ALL LEVELS
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 8
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
Course Progression Map: Technician OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
years of experience
TECHNICIAN
Suggested no of
OPERATIONS MAINTENANCE
MECHANICAL & INSPECTION
EXPLORATION & PRODUCTION PROCESS & ANALYTICAL ELECTRICAL INSTRUMENTATION
STATICS INSPECTION ROTATING
✓Plant Process Troubleshooting ✓Tankage and Storage ✓ Introduction to Piping ✓Integrated Module ** ✓DOMI Pump ✓Low Voltage Switchboard & Switchgear Equipment ✓Fundamental of Integrated Control
✓Plant Monitoring & Optimisation ✓Piping and Valves System ** (general inspection) ✓DOMI Gas Turbine Operation & Maintenance Safety System (ICSS)
✓P&ID & Schematic Diagram ✓Downstream Plant Familiarisation ✓ DOMI Static Equipment ** ✓Welding Technology ✓DOMI Compressor & ✓Maintenance and Troubleshooting of LV Motors ✓Process Measurement I
✓Plant Start-up & Shutdown (cover all statics equipment) Blowers (AC/DC) ✓Control Valve
✓P&ID & Schematic Diagram ✓ Pressure Relieving Devices ✓Condition Monitoring ✓Generator Operation & Control System ✓Quality Measuring Instrument
✓Distillation Principles (Pilot Plant and CBT) ✓ Lifting and Rigging ** ✓ASNT UTTM Equipment ✓Portable Equipment and Temporary Installation ✓Vibration Monitoring System
1-3 years
BASIC
✓Water and Waste Water Treatment System ✓ Valves and Safety Valves ✓DOMI Rotating Equipment ✓Protection Relay & Coordination ✓Gas Detection System
✓Pump Operation and Care Maintenance & Repair ✓Single Stage Centrifugal ✓Generating Equipment & System ✓Introduction to the Distributed Control
✓Heat Exchangers: Operation and Care ✓ Tank Maintenance** Pump ✓Basic Application of Ex Equipment in Hazardous Area System (DCS) Operation -ExperionPKS
✓Alignment Principles & for Process Operator
Technology ✓A0 Chargeman ✓Introduction to the Distributed Control
✓Reciprocating Compressor ✓IECEx Unit Ex001 Competency Training System (DCS) Operation -Yokogawa CS
✓Positive Displacement Programme 3000 for Process Operator Legend:
Pump
✓Instrument Fitter
Programme is
** available upon
✓Produced Water Treatment System ✓Plant Monitoring & Optimisation ✓DOMI of Piping System & ✓Non Destructive ✓Precision Practical ✓High Voltage Switching and Generator Synchronising ✓Plant Process Control & DCS System request
On The Platform ✓Piping and Valves Valve Testing Alignment ** Practice Operation
✓Crude Separation and Crude/ ✓Furnace ✓DOMI of Static (Fire) - boiler ✓Welding Inspection ✓Reciprocating Compressor ✓Condition Monitoring and Maintenance of HV ✓Process Control Theory and Application
Condensate Stabilisation ✓Tankage and Storage fire equipment ** Level 2 Switchgears and Transformers ✓Instrumented Safeguarding System
✓Gas Dehydration and Regeneration ✓Plant Process Troubleshooting (L2) ✓Welding Technology ✓Positive Displacement Pump ✓Maintenance and Troubleshooting of AC & DC Ups ✓Liquid and Gas Metering Professional
System ✓Compressor, Fan and Blowers: Operation and Care ✓Non Destructive Testing ✓Diesel Engine : Operation & System ✓Safety PLC-Tricon TMR
✓Oil and Gas Terminal Operation ✓Heat Exchangers: Operation and Care Maintenance ✓Testing, Precommisisoning and Commissioning of ✓Programmable Logic Controller -Allen
Development
INTERMEDIATE
✓Hydrocarbon Treatment System ✓Water and Waste Water Treatment System ✓Gas Turbine Operation & Electrical Equipment Bradley CLX5000 Programme (PDP)
✓Plant Process Troubleshooting ✓Distillation Principles (Pilot Plant and CBT) Maintenance ✓Electrical Protection System ✓Honeywell EPKS Engineering &
✓Plant Monitoring & Optimisation ✓Mechanical Seal ✓IQ Motor Operated Valve (MOV) Maintenance
4-8 years
✓Gaslift Operations and Optimisation ✓Tankage and Storage ✓Pump Troubleshooting ✓HV System Switching ✓P&ID Tuning
✓Wellhead and Production Header ✓Piping and Valves
ADVANCED
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 9
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
Course Progression Map: Technician OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
TECHNICIAN
HEALTH, SAFETY & ENVIRONMENT
✓PCSB PTW Level 2 Certification Programme ✓Safe Handling of Chemicals (SHOC) ✓RA Tools Training (BowTie, HAZID, ✓AGT for Non-Confined Space ✓BASEL Convention
✓PCSB PTW Level 3 Certification Programme ✓Hearing Conservation Awareness HAZOP, P-HAZOP and PASR ✓Basic First Aid (Knowledge Level) ✓Environmental Management Awareness
Application ✓Job Hazard Analysis (JHA) ✓CePSWaM Field Training Report Preparation
✓CePSWaM ✓Mercury Awareness Workshop (FTR) _KL
✓Authorised Entrant and Standby Person ✓CePSWaM Field Training Report Preparation
for Confined Space (AESP) - Level 1 Workshop (FTR)
✓Authorised Entrant and Standby Person ✓Handling of Scheduled Waste
for Confined Space -Refresher (AESP)
Level 1
Legend:
ALL LEVELS
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 10
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
Professional
Development
Programme (PDP)
Page 11
OTS PDP: Exploration & Production (E&P) OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER :
MOHAMAD MUAZ BIN ABDUL RASID COURS 2020
PROG. MIN MAX DURATION
+609-668 6148 LEVEL VENUE E FEE
TYPE PAX PAX (DAYS)
+6016-656 9468 (RM)
mohamadmuaz.abdrasi@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 12
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS PDP: Exploration & Production (E&P) OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER :
MOHAMAD MUAZ BIN ABDUL RASID 2020
PROG. COURSE MIN MAX DURATION
+609-668 6148 LEVEL VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+6016-656 9468
mohamadmuaz.abdrasi@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
TECHNICIAN PROGRAMME
19 OTS PDP : Basic Petroleum Prod, Transportation & Processes, L2 2 F2F (NR) KL 3,490 4 20 3
20 OTS PDP : Crude Separation and Crude/ Condensate Stabilization, L2 2 F2F (NR) KL 3,490 8 20 3
21 OTS PDP : Gaslift Operations and Optimisation, L2 2 F2F (NR) INSTEP* 2,070 6 20 3
22 OTS PDP : Gas Compression and Compressor Operation & Control, L2 2 F2F (NR) KL 3,490 4 20 3
23 OTS PDP : Gas Dehydration and Regeneration System, L2 2 F2F (NR) KL 3,490 4 20 3 Upon Request
24 OTS PDP : Heat Exchanger Operation & Maintenance, L2 2 F2F (NR) KL 3,490 5 20 3
25 OTS PDP : Hydrocarbon Treatment System, L2 2 F2F (NR) KL 3,490 5 20 3
26 OTS PDP : Oil and Gas Terminal Operation, L2 2 F2F (NR) KL 3,490 8 20 3
27 OTS PDP : Petroleum Liquid and Gas Properties, L2 2 F2F (NR) KL 3,490 4 20 3
28 OTS PDP : Pipe, Valve, Fitting & PNID, L2 2 F2F (NR) INSTEP* 3,490 9 20 3 10-12
29 OTS PDP : Produced Water Treatment System On The Platform, L2 2 F2F (NR) INSTEP* 3,490 4 20 3 07-09
30 OTS PDP : Separator Operation , L2 2 F2F (NR) INSTEP* 3,490 8 20 3 Upon Request
31 OTS PDP : Wellhead and Production Header System , L2 2 F2F (NR) INSTEP* 2,070 4 20 3 23-25
32 OTS PDP : Water Injection System, L2 2 F2F (NR) INSTEP* 3,490 4 20 3 05-07
33 OTS PDP : Watermaker Operation & Maintenance , L2 2 F2F (NR) KL 3,490 8 20 3 Upon Request
TRAINING PLANT OPERATION - UPSTREAM
34 OTS PDP : Plant Process Troubleshooting, L2 2 F2F (NR) INSTEP* 4,490 5 20 3
35 OTS PDP : Plant Start-up & Shutdown, L2 2 F2F (NR) INSTEP* 8,970 5 20 5
36 OTS PDP : Plant Monitoring & Optimization, L2 2 F2F (NR) INSTEP* 5,800 5 20 3 Upon Request
37 OTS PDP : PNID & Schematic Diagram, L2 2 F2F (NR) INSTEP* 5,800 5 20 3
38 OTS PDP : Upstream Plant Familiarization, L2 2 F2F (NR) INSTEP* 4,680 5 20 2
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 13
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS PDP: Process & Analytical (P&A) Process Operations OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER:
AHMAD YUSUF B HUSSAIN 2020
PROG. COURSE MIN MAX DURATION
+609-668 6226 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+6013-239 0864
yusuf.hussain@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
1 OTS PDP : Compressor, Fan and Blowers: Operation and Care F2F (NR) INSTEP* 4,200 15 20 3 05-07
2 OTS PDP : Cooling Water F2F (NR) INSTEP* 4,200 15 20 3 07-09
3 OTS PDP : Filter and Strainer: Operation and Care F2F (NR) INSTEP* 3,100 15 20 2
4 OTS PDP : Furnace F2F (NR) INSTEP* 3,100 15 20 2 24-25 21-22
5 OTS PDP : Gas Turbine: Operation and Care F2F (NR) INSTEP* 4,200 15 20 3 21-23 01-03
6 OTS PDP : Heat Exchangers: Operation and Care F2F (NR) INSTEP* 4,200 15 20 3 17-19 19-21
7 OTS PDP : Piping and Valves F2F (NR) INSTEP* 4,200 15 20 3 24-26 01-03
8 OTS PDP : Plant Air Systems F2F (NR) INSTEP* 3,100 15 20 2 09-10
9 OTS PDP : Pump Operation and Care F2F (NR) INSTEP* 4,200 15 20 3 07-09
10 OTS PDP : Reactor: Operation and Care F2F (NR) INSTEP* 4,200 15 20 3 21-23
11 OTS PDP : Steam Turbine : Operation & Care F2F (NR) INSTEP* 4,200 15 20 3 07-09 14-16
12 OTS PDP : Tankage and Storage F2F (NR) INSTEP* 4,200 15 20 3 07-09 02-04
13 OTS PDP : Terminal Operation F2F (NR) INSTEP* 3,100 15 20 2 19-20
14 OTS PDP : Utility: Flare, LDS & Fuel Gas System F2F (NR) INSTEP* 4,200 15 20 3 24-26 23-25
15 OTS PDP : Water and Waste Water Treatment System F2F (NR) INSTEP* 4,200 15 20 3 10-12 02-04 01-03
16 OTS PDP : Distillation Principles (Pilot Plant and CBT) F2F (NR) INSTEP* 3,180 10 15 3 05-07
17 OTS PDP : Fundamentals Process Control System Engineering F2F (NR) INSTEP* 3,500 12 15 4 19-22
18 OTS PDP : Separation Process F2F (NR) INSTEP* 3,100 15 20 2 10-11 02-03
TRAINING PLANT OPERATION - DOWNSTREAM
19 OTS PDP : Downstream Plant Familiarization F2F (NR) INSTEP* 2,530 12 12 2 Upon Request
20 OTS PDP : Equipment Preparation for Maintenance (Isolation) F2F (NR) INSTEP* 3,850 10 10 3 2-4
21 OTS PDP : Plant Monitoring & Optimization F2F (NR) INSTEP* 3,850 10 10 3
22 OTS PDP : Plant Process Troubleshooting (L2) F2F (NR) INSTEP* 3,850 10 10 3
Upon Request
23 OTS PDP : Plant Start-up & Shutdown F2F (NR) INSTEP* 6,200 10 10 5
24 OTS PDP : Plant Turnaround Management F2F (NR) INSTEP* 6,200 10 10 5
25 OTS PDP : PNID & Schematic Diagram F2F (NR) INSTEP* 3,850 10 10 3 21-23
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 14
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS PDP: Process & Analytical (P&A) Laboratory OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER :
AHMAD YUSUF B HUSSAIN 2020
PROG. COURSE MIN MAX DURATION
+609-668 6226 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+6013-239 0864
yusuf.hussain@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
1 OTS PDP : Calibration Requirements of Laboratory Equipment F2F (NR) INSTEP* 4,200 10 20 3 23-25
2 OTS PDP : Fundamental of Analysis and Hydrocarbon Chemistry F2F (NR) INSTEP* 3,100 10 20 2 02-03
3 OTS PDP : Inventory and Record F2F (NR) INSTEP* 3,100 10 20 2 07-08
4 OTS PDP : Laboratory Safety F2F (NR) INSTEP* 4,200 10 20 3 Upon Request
5 OTS PDP : Maintenance and Troubleshooting of Gas Chromatograph F2F (NR) INSTEP* 3,910 8 20 3 24-26
6 OTS PDP : Physical and Biological Techniques F2F (NR) INSTEP* 4,200 10 20 3 14-16
7 OTS PDP : Principles and Calibration of Gas Chromatograph F2F (NR) INSTEP* 4,200 10 20 3
8 OTS PDP : Reagent Preparation and Standardisation (Refresher) F2F (NR) INSTEP* 2,740 9 20 2
Upon Request
9 OTS PDP : Sample Management and Field Testing F2F (NR) INSTEP* 4,200 10 20 3
10 OTS PDP : Spectroscopy Technique Analysis F2F (NR) INSTEP* 4,200 10 20 3
11 OTS PDP : Titration and Electrochemistry F2F (NR) INSTEP* 4,200 10 20 3 12-14
12 OTS PDP : Water & Wastewater Analysis F2F (NR) INSTEP* 3,180 10 20 3 Upon Request
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 15
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS PDP: Mechanical Engineering OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER :
MUHAMMAD SHAMIL BIN ZULKIPLI 2020
PROG. COURSE MIN MAX DURATION
+609-668 6045 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+6013-278 9357
mshamil.zulkipli@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
1 OTS PDP : Alignment Principles & Technology F2F (NR) INSTEP* 2,090 10 15 3
2 OTS PDP : Condition Monitoring of Rotating Equipment F2F (NR) INSTEP* 2,090 10 15 3
OTS PDP : Design, Operation, Maintenance & Inspection of Compressors
3 F2F (NR) INSTEP* 2,090 5 25 3
& Blowers
Upon Request
4 OTS PDP : Design, Operation, Maintenance & Inspection of Gas Turbines F2F (NR) INSTEP* 2,090 5 25 3
5 OTS PDP : Design, Operation, Maintenance & Inspection of Pumps F2F (NR) INSTEP* 2,090 5 25 3
OTS PDP : Design, Operation, Maintenance & Inspection of Rotating
6 F2F (NR) INSTEP* 2,610 5 25 4
Equipment
7 OTS PDP : Diesel Engine : Operation & Maintenance F2F (NR) KL 3,580 15 20 4 05-08
8 OTS PDP : Flange Management Training F2F (NR) INSTEP* 3,590 5 20 3 Upon Request
9 OTS PDP : Mechanical Seal Maintenance and Troubleshooting F2F (NR) KL 3,380 15 20 3 19 - 21
10 OTS PDP : Non Destructive Testing F2F (NR) INSTEP* 2,680 10 15 4 Upon Request
11 OTS PDP : Piping System Maintenance (Pipes and Fititng) F2F (NR) INSTEP* 1,680 5 20 2 29-30
12 OTS PDP : Positive Displacement Pump F2F (NR) INSTEP* 2,180 10 15 2 24-25
13 OTS PDP : Precision Practical Alignment F2F (NR) INSTEP* 3,030 10 15 3 17 - 19
14 OTS PDP : Pressure Relieving Devices F2F (NR) INSTEP* 2,180 10 15 2
15 OTS PDP : Pump Troubleshooting F2F (NR) INSTEP* 2,180 10 15 2 17-18
16 OTS PDP : Reciprocating Compressor F2F (NR) INSTEP* 3,030 10 15 3
17 OTS PDP : Single Stage Centrifugal Pump F2F (NR) INSTEP* 3,030 10 15 3 Upon Request
18 OTS PDP : Valves and Safety Valves Maintenance & Repair F2F (NR) INSTEP* 3,030 10 15 3
19 OTS PDP : Welding Inspection F2F (NR) INSTEP* 2,130 10 15 3 29 Sept-01 Oct
20 OTS PDP : Welding Technology F2F (NR) INSTEP* 2,610 10 15 4 7-10
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 16
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS PDP: Electrical OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER :
MUHAMMAD BADIUZZAMAN BIN RUSLI 2020
PROG. COURSE MIN MAX DURATION
+609-668 6289 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+6019-341 7612
mbadiuzzaman.rusli@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 17
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS PDP: Instrumentation & Control OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER:
M NAZMI MIZAN 2020
PROG. COURSE MIN MAX DURATION
+609-668 6322 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+6017-909 6972
mnazmi.mizan@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
PROGRAMME LEADER :
RAJA SURIDA BT SAIFUL BAHRI 2020
PROG. COURSE MIN MAX DURATION
+609-668 6346 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+6016-333 4094
rajasurida.sb@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 19
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS PDP: Health, Safety & Environment (HSE) OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER :
RAJA SURIDA BT SAIFUL BAHRI 2020
PROG. COURSE MIN MAX DURATION
+609-668 6346 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+6016-333 4094
rajasurida.sb@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 20
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS PDP: General Studies OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER:
MUHAMMAD BADIUZZAMAN BIN RUSLI 2020
PROG. COURSE MIN MAX DURATION
+609-668 6289 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+6019-341 7612
mbadiuzzaman.rusli@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
1 OTS PDP : English Speaking Empowerment for NET F2F (NR) Labuan 2,410 15 20 3 26-28
Kota
2 OTS PDP : English Speaking Empowerment for NET F2F (NR) 2,800 15 20 3 05-07
Kinabalu
3 OTS PDP : English Speaking Empowerment for NET F2F (NR) INSTEP 1,990 15 20 3 01-03
4 OTS PDP : English Speaking Empowerment for NET (VILT) VILT MS Teams 1,340 15 20 3 22-24
5 OTS PDP : English Writing Empowerment for NET F2F (NR) KL 2,270 15 20 3 24-26
6 OTS PDP : English Writing Empowerment for NET F2F (NR) Johor Bharu 2,420 15 20 3 22-24
Kota 30 Nov-
7 OTS PDP : English Writing Empowerment for NET F2F (NR) 2,800 15 20 3 17-19
Kinabalu 02 Dec
8 OTS PDP : English Writing Empowerment for NET (VILT) VILT MS Teams 1,340 15 20 3 13-15
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 21
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
Assessment & Certification
(A&C)
Page 22
OTS A&C: Exploration & Production (E&P) Special Project OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER :
SITI SUHAILI SHUIB 2020
PROG. COURSE MIN MAX DURATION
+609-668 6150 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+6013-586 8208
sitisuhaili.shuib@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
ADVANCED PIGGING OPERATION CERTIFICATION SCHEME (APOCS)
1 OTS A&C : Advanced Pigging Operation Certification Scheme (APOCS) F2F (NR) INSTEP* 7,000 10 20 5 09-13 20-24 18-22 22-26 06-10
UPSTREAM PANEL OPERATOR CERTIFICATION PROGRAMME (UPOCP)
OTS A&C : UPOCP: Control Room Operator Emergency Response
1 F2F (NR) INSTEP* 7,000 6 6 3 10-12 07-09 16-18
Preparedness (CRO-ERP)
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 23
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS A&C: Process & Analytical (P&A) CEPIETSO (BP) OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER :
SITI SUHAILI SHUIB 2020
PROG. COURSE MIN MAX DURATION
+609-668 6150 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+6013-586 8208
sitisuhaili.shuib@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 24
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS A&C: Mechanical & Instrumentation (M&I) OFF-THE-SHELF
Plant Management System (PMS) LEARNING CALENDAR
2 0 2 0
Plant Management System (PMS) previously known as Pengerang Integrated Complex Osh Administration Transformation (PICOAT)
PROGRAMME LEADER:
HASIF SHEIKH ALI 2020
PROG. COURSE MIN MAX DURATION
+609-668 6020 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+6013-325 8603
hasif.sheikhali@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
PMS: INTERNAL REGULATOR COMPETENCY PROGRAMME (IRCP)
1 OTS A&C : IRCP Assessment and Certification F2F (NR) Johor Bahru 1,520 17 20 1 07
2 OTS A&C : IRCP: Plant Management System (PMS) F2F (NR) Johor Bahru 4,200 16 20 4 13-16 07-10
3 OTS A&C : IRCP: Compliance to FMA 1967 and Regulations F2F (NR) Johor Bahru 2,100 10 15 2 22-23 25-26
4 OTS A&C : IRCP: Compliance to Regulations Under OSHA 1994 F2F (NR) Johor Bahru 2,100 10 15 2 26-27
5 OTS A&C : IRCP: ISO 45001:2018 Requirements F2F (NR) Johor Bahru 2,690 10 15 2 11-12 18-19
6 OTS A&C : IRCP: ISO 45001:2018 Lead Auditor (IRCA & CQI Certified) F2F (NR) Johor Bahru 6,910 10 10 5 24-28 23-27
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 25
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS A&C: Mechanical & Instrumentation (M&I) OSR Inspector OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER :
M SHAMIL BIN ZULKIPLI 2020
PROG. COURSE MIN MAX DURATION
+609-668 6045 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+6013-278 9357
mshamil.zulkipli@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 26
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS A&C: Electrical IECEx Competency Training OFF-THE-SHELF
Programme & Assessment LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER:
MUHAMAD FAIZZUDIN BIN AHMAD AZHAR 2020
PROG. COURSE MIN MAX DURATION
+609-668 6120 VENUE
TYPE FEE (RM)** PAX PAX (DAYS)
+014-512 8724
muhamadfaizzudin.ah@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
OTS A&C : IECEx Unit Ex001 Competency Training Programme &
1 VILT MS Teams 4,950 5 10 2 07-09
Assessment **
OTS A&C : IECEx Unit Ex001 & Ex003 Competency Training Programme &
2 F2F (NR) INSTEP* 8,430 5 8 4 24-27 14-17
Assessment **
OTS A&C : IECEx Unit Ex001, Ex007 & Ex008 Competency Training
3 F2F (NR) INSTEP* 8,850 5 8 4 30 Nov-03 Dec
Programme & Assessment **
OTS A&C : IECEx Unit Ex001, Ex003, Ex007 & Ex008 Competency Training
4 F2F (NR) INSTEP* 11,650 5 8 5 27 Sept-01 Oct
Programme & Assessment **
OTS A&C : IECEx Unit Ex001, Ex004, Ex007 & Ex008 Competency Training
5 F2F (NR) INSTEP* 11,650 5 8 5 06-10 08-12
Programme & Assessment **
OTS A&C : IECEx Unit Ex001 & Ex009 Competency Training Programme &
6 F2F (NR) KL 9,690 5 8 4 19-22
Assessment **
7 OTS A&C : IECEx Refresher (Exclude Examination) F2F (NR) INSTEP* 670 N/A 1 Upon Request
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 27
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS A&C: Electrical Chargeman Programme OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER:
MUHAMAD FAIZZUDIN BIN AHMAD AZHAR 2020
PROG. COURSE MIN MAX DURATION
+609-668 6120 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+014-512 8724
muhamadfaizzudin.ah@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
1 OTS A&C : A0 Chargeman F2F (NR) INSTEP* 15,030 15 15 80 09 Feb - 01 Oct TBC
2 OTS A&C : A4 Chargeman F2F (NR) INSTEP* 18,710 12 12 100 09 Aug - 31 Dec
3 OTS A&C : B0 Chargeman F2F (NR) INSTEP* 20,990 14 14 100 TBC
4 OTS A&C : B4 Chargeman F2F (NR) INSTEP* 22,810 10 10 100 Session in 2021
5 OTS A&C : Low Voltage Overhead Lines F2F (NR) INSTEP* 4,690 20 20 10 20 Sep -1 Oct
6 OTS A&C : High Voltage Overhead Lines F2F (NR) INSTEP* 6,980 10 10 13 07-23 12 - 28
7 OTS A&C : Low Voltage Generator And Synchronizing F2F (NR) INSTEP* 5,440 10
N/A Upon Request
8 OTS A&C : High Voltage Generator And Synchronizing F2F (NR) INSTEP* 6,490 10
*Inclusive of Experiential Learning at UDTP, INSTEP.
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 28
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS A&C: Instrumentation OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER:
MUHAMAD FAIZZUDIN BIN AHMAD AZHAR 2020
PROG. COURSE MIN MAX DURATION
+609-668 6120 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+014-512 8724
muhamadfaizzudin.ah@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
OTS A&C : Certified Personnel for Metering Validation And Calibration
1 F2F (NR) INSTEP* 6,110 4 8 5 27 Sept-01 Oct 22-26
Competency Programme
2 OTS A&C : Instrument Fitter F2F (NR) INSTEP* 4,310 4 8 4 12-15 07-10
*Inclusive of Experiential Learning at UDTP, INSTEP.
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 29
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS A&C: Health, Safety & Environment (HSE) Authorised Entrant OFF-THE-SHELF
and Standby Person for Confined Space (AESP) LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER:
HASIF SHEIKH ALI 2020
PROG. COURSE MIN MAX DURATION
+609-668 6020 VENUE
TYPE FEE (RM) PAX PAX (DAYS)
+6013-325 8603
hasif.sheikhali@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
5-6
1 OTS A&C : Authorised Entrant and Standby Person for Confined Space F2F (R) INSTEP* 870 10 20 2 25-26
16-17
OTS A&C : Authorised Entrant and Standby Person for Confined Space
2 F2F (R) INSTEP* 520 20 20 1 Upon Request
Refresher
*Inclusive of Experiential Learning at UDTP, INSTEP.
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 30
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS A&C: Health, Safety & Environment (HSE) CePSWaM OFF-THE-SHELF
LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER :
SITI SUHAILI SHUIB 2020
PROG. COURSE MIN MAX DURATION
+609-668 6150 VENUE
TYPE FEE (RM) PAX PAX (days)
+6013-586 8208
sitisuhaili.shuib@petronas.com.my JAN FEB MAC APR MAY JUNE JULY AUG SEPT OCT NOV DEC
Page
▪ Course fee stated above EXCLUDES tax
▪ Prog. type is subject to change: 31
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
OTS A&C: Health, Safety & Environment (HSE) PCSB Permit to Work OFF-THE-SHELF
(PTW) Competency Level 2: New Candidate & Refresher LEARNING CALENDAR
2 0 2 0
PROGRAMME LEADER:
NURUL NADIA BINTI MOHAMAD SABRY 2020
PROG. DURATION
+609-668 6078 LEVEL VENUE COURSE FEE (RM) MIN PAX MAX PAX
TYPE (DAYS)
+6019-522 6554
nurulnadia.mohamads@petronas.com.my AUG SEPT OCT NOV DEC
03-05
05-07 02-04
04-06 02-04 01-03
06-08 9-11
10-12 21-23 07-09
VILT MS Teams 700 20 20 3 13-15 10-12
11-13 22-24 14-16
20-22 17-19
18-20 28-30 15-17
26-28 24-26
25-27
INSTEP 1,050 15 20 3 24-26 28-30 5-7 9-11 14-16
04-06 02-04 06-08 03-05 01-03
Shah Alam 1,050 15 20 3 11-13 22-24 13-15 10-12 08-10
18-20 28-30 26-28 23-25 15-17
01-03 05-07
04-06 02-04 01-03
1 OTS A&C : PCSB Permit to Work Competency Level 2- New Candidate 2 13-15 13-15
11-13 09-11 07-09
Kerteh 1,050 15 20 3 20-22 18-20
17-19 16-18 09-11
23-25 21-23
25-27 23-25 15-17
F2F (NR) 28-30 26-28
10-12
Kota 02-04 12-14 09-11 01-03
1,050 15 20 3 17-19
Kinabalu 28-30 26-28 23-25 07-09
24-26
03-05
05-07 02-04
04-06 02-04 01-03
06-08 09-11
10-12 21-23 07-09
Miri 1,050 15 20 3 13-15 10-12
11-13 22-24 14-16
20-22 17-19
18-20 28-30 15-17
26-28 24-26
25-27
PROGRAMME LEADER:
NURUL NADIA BINTI MOHAMAD SABRY 2020
PROG. COURSE FEE (RM) DURATION
+609-668 6078 LEVEL VENUE MIN PAX MAX PAX
TYPE Inclusive of tax (DAYS)
+6019-522 6554
nurulnadia.mohamads@petronas.com.my AUG SEPT OCT NOV DEC
01
04 05 02 02
05 09 06 03 06
17 10 12 09 07
1 OTS A&C : PCSB Permit to Work Competency Level 2- Refresher 2 VILT MS Teams 450 10 10 1
18 23 13 10 21
24 24 19 23 22
25 20 24 28
29
Page
▪ Course fee stated above EXCLUDES tax , except for PTW Level 2- Refresher
▪ Prog. type is subject to change: 32
» F2F : Face-to-Face Experiential Learning
» VILT : Virtual Instructor-Led Training
HOME
» R : Residential
» NR : Non-residential PETRONAS Technical Training Sdn Bhd (956097-W)
REV5/AUG2020
GLOBAL GETENERGY OUTSTANDING PEARSON LEARNER MALAYSIAN SOCIETY FOR HUMAN RESOURCES DEVELOPMENT
AWARD 2019 AWARD OCCUPATIONAL SAFETY & HEALTH AWARDS 2017
Localisation Award 2016, 2017, 2018 & 2019 GOLD CLASS 1 AWARD 2017 & 2018 Data Analytics Category
Certificate IV in
Training & Assessment
34
“ Experiencing is Enriching ”
THANK YOU