Professional Documents
Culture Documents
EtherBERT 2022.01.16 13.31.32
EtherBERT 2022.01.16 13.31.32
| |
FAIL
Table of contents
SUMMARY ......................................................................................................... 1
TEST RESULTS .................................................................................................. 5
TEST SETUP ...................................................................................................... 5
FUNCTIONS ....................................................................................................... 5
SYSTEM INFORMATION ...................................................................................... 8
LOGGER .......................................................................................................... 11
SUMMARY
Results Summary
Test Status
Test Status Completed
Pass/Fail Verdict FAIL
Start Time 1/16/2022 01:30:29 PM
Duration 00d:00:01:01
Test Recovery 0
Service Disruption
Longest Shortest Total duration
Last (ms) Average (ms) Count Verdict
(ms) (ms) (ms)
0.950 0.445 0.445 0.697 1.395 2 PASS
RX Power Level
Min Max
Power Range (dBm) -14.4 0.5
RX Power Level (dBm) -5.1 -4.4
RX Frequency
Max Negative Offset Max Positive Offset
Frequency Offset (ppm) -0.4 14.7
Alarms/Errors
Alarms/Errors List
Active/Historical Alarms/Errors LOS, L Fault Det, Link Down, No Traffic
Interface
Alarms Seconds
LOS 1
Frequency 0
Clock Sync
Alarm Seconds
LOC 0
Ethernet
Alarms Seconds
Link Down 1
Local Fault Detected 1
Local Fault Received 0
Remote Fault 0
IP/UDP/TCP
Errors Seconds Count Rate
IP Checksum 0 0 0.00E00
UDP Checksum 0 0 0.00E00
TCP Checksum 0 0 0.00E00
Total 0
Setup Summary
Application Type EtherBERT - Framed
Interface Port 1
Interface/Rate 10GE LAN
Connector SFP+
Duplex --
Flow Control None
Remote Fault Emulation Disabled
Framing: MAC/IP/UDP
IP Version IPv4
EtherType 0x0800
Automatic IP (DHCP) Disabled
TTL 128
TOS 0x00
Default Gateway Disabled
BER
TX RX
Pattern PRBS31 Non-Inverted PRBS31 Non-Inverted
Bit Error
Pass/Fail Verdict Bit Error Rate
BER Threshold 1.0E-12
Service Disruption
No Traffic Time (ms) 0.1
Pass/Fail Verdict Enabled
SDT Threshold (ms) 50.0
TEST RESULTS
Ethernet Traffic
Frame Type TX Count RX Count
Multicast 0 0
Broadcast 0 0
Non-Unicast 0 0
TEST SETUP
Clock Synchronization
Clock Mode Internal
FUNCTIONS
Ping
Timeout (ms) 4000
Delay (ms) 1000
Data Size (Bytes) 32
TTL 128
Type Of Service (TOS) 0x00
Ping Statistics
Packets Transmitted --
Packets Received --
Percentage Lost (%) --
Minimum Round Trip Time (ms) --
Maximum Round Trip Time (ms) --
Average Round Trip Time (ms) --
Trace Route
Timeout (ms) 4000
Max Hop Count 128
Filter 2
Filter 7
SYSTEM INFORMATION
Pluggable Module
Module ID SFP+
Hardware Revision A
Connector Type LC
Wavelength 1310 nm
SONET/SDH: Single-Mode Fiber, FC: Single-Mode Fiber, 10G: Single-
Mode
Mode Fiber
Power Class Power Class 1 Module (<= 1W max)
Software Options
SDH Synchronous Digital Hierarchy Enabled
SONET Synchronous Optical Network Enabled
622M 622 Mbit/s Enabled
155M 155 Mbit/s Enabled
2488M 2.488 Gbit/s Enabled
10G_LAN Ethernet 10G LAN optical interface Enabled
LOGGER
ID Time Event Duration Details
1 01/16 01:30:29 PM Test Started 2022-01-16
2 01/16 01:31:05 PM LOS 00:00:01
3 01/16 01:31:05 PM Link Down 00:00:01
4 01/16 01:31:05 PM L Fault Det 00:00:01
5 01/16 01:31:05 PM SDT 0.445 ms
6 01/16 01:31:06 PM No Traffic 00:00:01
7 01/16 01:31:30 PM Test Stopped FAIL