Professional Documents
Culture Documents
EtherSAM (Y.1564) 2022.07.20 23.45.07
EtherSAM (Y.1564) 2022.07.20 23.45.07
| |
FAIL
Table of contents
SUMMARY ......................................................................................................... 1
TEST RESULTS .................................................................................................. 5
TEST SETUP ...................................................................................................... 6
FUNCTIONS ....................................................................................................... 9
SYSTEM INFORMATION ...................................................................................... 9
LOGGER .......................................................................................................... 12
SUMMARY
Results Summary
Test Status
Service Configuration Test Status Completed, Pass
Service Performance Test Status Aborted, Link Down Alarm
Pass/Fail Verdict FAIL
Start Time 7/20/2022 02:30:22 PM
Duration 00d:06:34:32
Test Recovery 0
EtherSAM
Services Summary
Service Name Service Configuration Test Service Performance Test
1 Service 1 PASS PASS
RX Power Level
Min Max
Power Range (dBm) -14.4 0.5
RX Power Level (dBm) -1.4 -1.2
RX Frequency
Max Negative Offset Max Positive Offset
Frequency Offset (ppm) 0.0 0.8
Alarms/Errors
Alarms/Errors List
Active/Historical Alarms/Errors L Fault Rcd, Link Down
Interface
Alarms Seconds
LOS 0
Frequency 0
Ethernet
Alarms Seconds
Link Down 4
Local Fault Detected 0
Local Fault Received 4
Remote Fault 0
Clock Sync
Alarm Seconds
LOC 0
IP/UDP/TCP
Errors Seconds Count Rate
IP Checksum 0 0 0.00E00
UDP Checksum 0 0 0.00E00
TCP Checksum 0 0 0.00E00
Total 0
Setup Summary
Application Type EtherSAM (Y.1564)
Interface Port 1
Interface/Rate 10GE LAN
Connector SFP+
Duplex --
Flow Control None
EtherSAM
Pass/Fail Verdict Enabled
Sub-Tests
Service Configuration Test Service Performance Test
Ramp Test Enabled Status Enabled
Burst selection Disabled Duration 01d:00:00:00
Duration (s) 25
Ramp
Step Time (s) 5
Step Values
1 50 %
2 75 %
3 90 %
4 100 %
Services
Total Committed TX Rate (%) 99.9000
Services Summary
Max Max
Service Frame Size Frame CBS
Profile CIR (%) Jitter Latency
Name (Bytes) Loss Rate (Bytes)
(ms) (ms)
1 Service 1 Data 9160 99.9000 0.015 70.0 1.0E-03 --
TEST RESULTS
Ethernet Traffic
Frame Type TX Count RX Count
Multicast 0 0
Broadcast 2 2
Non-Unicast 2 2
Excess Steps
Frame Loss Max Jitter Max Latency Max Throughput
Step Verdict
Rate (ms) (ms) (%)
Traffic Policing 0.0E-00 < 0.015 24.801 99.8999 PASS
TEST SETUP
Clock Synchronization
Clock Mode Internal
IP Version IPv4
Service 1
Service Profile
Service Name Service 1
Profile Data
Frame Size Type Fixed
Frame Size (Bytes) 9160
SLA Parameters
Information Rate
CIR (%) 99.9000
Performance Criteria
Max Jitter (ms) 0.015
Max Latency (ms) 70.0
Frame Loss Rate 1.0E-03
Test Parameters
Traffic Policing (%) 99.9000
Framing
Frame Format Ethernet II
Network Layer IPv4
Transport Layer UDP
VLAN None
MPLS Disabled
Addressing
EtherType 0x0800
Automatic IP (DHCP) Disabled
TTL 128
TOS 0x00
Default Gateway Disabled
FUNCTIONS
Ping & Trace Route
Network
Source MAC Address 00:03:01:11:A5:6E
Source IP Address 10.10.165.110 (Stream 1)
Destination IP Address 0.0.0.0
Ping
Timeout (ms) 4000
Delay (ms) 1000
Data Size (Bytes) 32
TTL 128
Type Of Service (TOS) 0x00
Ping Statistics
Packets Transmitted --
Packets Received --
Percentage Lost (%) --
Minimum Round Trip Time (ms) --
Maximum Round Trip Time (ms) --
Average Round Trip Time (ms) --
Trace Route
Timeout (ms) 4000
Max Hop Count 128
SYSTEM INFORMATION
Pluggable Module
Module ID SFP+
Hardware Revision A
Connector Type LC
Wavelength 1310 nm
SONET/SDH: Single-Mode Fiber, FC: Single-Mode Fiber, 10G: Single-
Mode
Mode Fiber
Power Class Power Class 1 Module (<= 1W max)
Software Options
SDH Synchronous Digital Hierarchy Enabled
SONET Synchronous Optical Network Enabled
622M 622 Mbit/s Enabled
155M 155 Mbit/s Enabled
2488M 2.488 Gbit/s Enabled
10G_LAN Ethernet 10G LAN optical interface Enabled
LOGGER
ID Time Event Duration Details
1 07/20 02:30:22 PM Test Started 2022-07-20
2 07/20 02:30:25 PM Service Configuration test 2022-07-20
3 07/20 02:31:05 PM Service Performance test 2022-07-20
4 07/20 09:04:51 PM Link Down 00:00:04
5 07/20 09:04:51 PM L Fault Rcd 00:00:04
6 07/20 09:04:54 PM Test Stopped FAIL