Professional Documents
Culture Documents
Product Image
PIR unit
Remote fob
2 LED Indicator will be lighted up when the battery is low as below diagram F .
3 Insert a GSM SIM card as below diagram J . A click will be sounded once the SIM card is inserted
properly. The SIM card can be removed by pushing it.
4 This alarm does not support SIM card verification. Do not use PIN code for the SIM card.
2 Press the Learn code button C on the side of the remote fob;
5 The code is paired with the unit and the remote fob successfully.
Hold the learn code C and remove the batteries. Then the remote fob does not have code
programming connected with any main unit.
4 Once the main unit is triggered, it will auto dial the programmed phone number and repeatedly play
the voice message.
4 The green LED will flash 3 times to indicate that the numbers have been stored correctly.
To delete the stored numbers, press * 1 * ; * 2 * ; * 3 * ; the green LED will flash 3
times to indicate that the numbers have been deleted.
To reactivate SMS function (the alarm will send SMS and dial when it’s triggered) :
Indicator status
Status Indication
Green LED flashes in every 3 seconds GSM network is accessed with strong signal
SMS Alert for low battery, when you got the sms alert ,then if the unit be triggered , it
could siren ,but cannot make phone call and send sms, when the Red LED is on ,the
unit completely cannot work .
3
45°
10m
0°
45°
2 One ”beep” will be sounded as an indication that the unit has armed.
2 One “beep” will be sounded as an indication that the unit has disarmed.
All of the below models are compatible with CX901. Once they learn the programme code from the
same remote fob as CX901, they can be paired with CX901 to construct the whole alarm system.
Important
Please check with the supplier of the GSM SIM card that they have sufficient network coverage for the
area that the CX901 is intended to be installed.